SAFETY DATA SHEET FLOOR POLISH STRIPPER

Transcription

1 Revision Date 18/10/11 Supersedes date 31/10/10 SAFETY DATA SHEET SECTION 1: IDENTIFICATION OF THE SUBSTANCE/MIXTURE AND OF THE COMPANY/UNDERTAKING 1.1. Product identifier Product name Internal Id C Relevant identified uses of the substance or mixture and uses advised against Identified uses Detergent Details of the supplier of the safety data sheet Supplier 1.4. Emergency telephone number +44 (0) ARROW CLEANING & HYGIENE SOLUTIONS RAWDON ROAD MOIRA SWADLINCOTE DERBYSHIRE DE12 6DA TEL: +44 (0) EMERGENCY: +44 (0) FAX: +44 (0) SECTION 2: HAZARDS IDENTIFICATION 2.1. Classification of the substance or mixture Classification (1999/45/EEC) 2.2. Label elements Detergent Labelling: Physical and Chemical Hazards Not classified. Human health Environment C;R35. Xi;R37. Contains Label In Accordance With (EC) No. 1272/2008 Not classified. < 5% anionic surfactants perfumes Skin Corr. 1A - H314;STOT Single 3 - H335 Not classified. CITRAL,d-LIMONENE Signal Word Danger 1 / 6

2 Hazard Statements H314 Causes severe skin burns and eye damage. H335 May cause respiratory irritation. Precautionary Statements P271 Use only outdoors or in a well-ventilated area. P280 Wear protective gloves/protective clothing/eye protection/face protection. P IF ON SKIN (or hair): Remove/Take off immediately all contaminated clothing. Rinse skin with water/shower. P IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. P310 Immediately call a POISON CENTER or doctor/physician. P501a Dispose of contents to an approved disposal site Supplementary Precautionary Statements P260 Do not breathe dust/fume/gas/mist/vapours/spray. P261 Avoid breathing dust/fume/gas/mist/vapours/spray. P264 Wash thoroughly after handling. P IF SWALLOWED: Rinse mouth. Do NOT induce vomiting. P IF INHALED: Remove victim to fresh air and keep at rest in a position comfortable for breathing. P312 Call a POISON CENTER or doctor/physician if you feel unwell. P321 Specific treatment (see on this label). P363 Wash contaminated clothing before reuse. P Store in a well-ventilated place. Keep container tightly closed. P405 Store locked up Other hazards SECTION 3: COMPOSITION/INFORMATION ON INGREDIENTS 3.2. Mixtures 2-AMINOETHANOL 5-10% CAS-No.: EC No.: Acute Tox. 4 - H302 Acute Tox. 4 - H312 Acute Tox. 4 - H332 Skin Corr. 1B - H314 STOT Single 3 - H335 Classification (67/548/EEC) C;R34 Xn;R20/21/22 SODIUM DODECYL BENZENE SULPHONATE 1-5% CAS-No.: EC No.: Acute Tox. 4 - H302 Skin Irrit. 2 - H315 Eye Dam. 1 - H318 Classification (67/548/EEC) Xn;R22. Xi;R38,R41. SODIUM HYDROXIDE 0-1% CAS-No.: EC No.: Registration Number: Skin Corr. 1A - H314 Classification (67/548/EEC) C;R35 The Full Text for all R-Phrases and Hazard Statements are Displayed in Section 16. SECTION 4: FIRST AID MEASURES 2 / 6

3 4.1. Description of first aid measures Inhalation Provide rest, warmth and fresh air. Ingestion Rinse mouth thoroughly. DO NOT INDUCE VOMITING! Get medical attention immediately! Skin contact Rinse the skin immediately with lots of water. Get medical attention if irritation persists after washing. Eye contact Promptly wash eyes with plenty of water while lifting the eye lids. Continue to rinse for at least 15 minutes. Get medical attention if any discomfort continues Most important symptoms and effects, both acute and delayed Skin contact Burns can occur. Eye contact Extreme irritation of eyes and mucous membranes, including burning and tearing Indication of any immediate medical attention and special treatment needed SECTION 5: FIREFIGHTING MEASURES 5.1. Extinguishing media Extinguishing media This product is not flammable Special hazards arising from the substance or mixture Hazardous combustion products Vapours/gases/fumes of: Ammonia or amines Advice for firefighters Special Fire Fighting Procedures Avoid breathing fire vapours. SECTION 6: ACCIDENTAL RELEASE MEASURES 6.1. Personal precautions, protective equipment and emergency procedures Avoid inhalation of vapours and contact with skin and eyes Environmental precautions Contain spillages with sand, earth or any suitable adsorbent material Methods and material for containment and cleaning up Absorb spillage with suitable absorbent material. Flush contaminated area with plenty of water Reference to other sections Wear protective clothing as described in Section 8 of this safety data sheet. SECTION 7: HANDLING AND STORAGE 7.1. Precautions for safe handling Avoid spilling, skin and eye contact Conditions for safe storage, including any incompatibilities Store in tightly closed original container in a dry and cool place Specific end use(s) The identified uses for this product are detailed in Section 1.2. SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION 8.1. Control parameters 3 / 6

4 Name STD TWA - 8 Hrs STEL - 15 Min Notes 2-AMINOETHANOL SODIUM HYDROXIDE WEL 1 ppm(sk) ppm(sk) 7.6 mg/m3(sk) mg/m3(sk) WEL 2 mg/m3 WEL = Workplace Exposure Limit Exposure controls Protective equipment Engineering measures Provide adequate ventilation. Hand protection Chemical resistant gloves required for prolonged or repeated contact. Use protective gloves made of: Rubber, neoprene or PVC. Eye protection Wear approved chemical safety goggles where eye exposure is reasonably probable. SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES 9.1. Information on basic physical and chemical properties Appearance Liquid Colour Odour Solubility Red. Relative density 1.01 ph-value, Conc. Solution Other information Characteristic. Completely soluble in water SECTION 10: STABILITY AND REACTIVITY Reactivity The solution is strongly alkaline and reacts with strong acids with heat generation Chemical stability Stable under normal temperature conditions Possibility of hazardous reactions Hazardous Polymerisation Will not polymerise Conditions to avoid Avoid contact with acids and oxidising substances Incompatible materials Materials To Avoid Strong oxidising substances. Strong acids Hazardous decomposition products High temperatures generate: Corrosive gases/vapours/fumes of: Ammonia or amines. SECTION 11: TOXICOLOGICAL INFORMATION Information on toxicological effects Inhalation Upper respiratory irritation. 4 / 6

5 Ingestion Gastrointestinal symptoms, including upset stomach. Skin contact Causes burns. Eye contact Extreme irritation of eyes and mucous membranes, including burning and tearing. Medical Symptoms Extreme irritation of eyes and mucous membranes, including burning and tearing. SECTION 12: ECOLOGICAL INFORMATION Ecotoxicity Not regarded as dangerous for the environment Toxicity Acute Toxicity - Fish Not determined Persistence and degradability Degradability The product is expected to be biodegradable Bioaccumulative potential Bioaccumulative potential No data available on bioaccumulation Mobility in soil Mobility: The product is soluble in water Results of PBT and vpvb assessment Other adverse effects Not determined. SECTION 13: DISPOSAL CONSIDERATIONS Waste treatment methods Dispose of waste and residues in accordance with local authority requirements. SECTION 14: TRANSPORT INFORMATION UN number UN No. (ADR/RID/ADN) 1760 UN No. (IMDG) 1760 UN No. (ICAO) UN proper shipping name Proper Shipping Name CORROSIVE LIQUID N.O.S (2-aminoethanol) Transport hazard class(es) ADR/RID/ADN Class Class 8: Corrosive substances. IMDG Class 8 ICAO Class/Division 8 Transport Labels CORROSIVE 8 5 / 6

6 14.4. Packing group ADR/RID/ADN Packing group IMDG Packing group ICAO Packing group II II II Environmental hazards Environmentally Hazardous Substance/Marine Pollutant No Special precautions for user Tunnel Restriction Code (E) Transport in bulk according to Annex II of MARPOL73/78 and the IBC Code Not relevant SECTION 15: REGULATORY INFORMATION Safety, health and environmental regulations/legislation specific for the substance or mixture Uk Regulatory References C.H.I.P. The Chemicals (Hazard Information and Packaging for Supply) Regulations The Carriage of Dangerous Goods by Road and Rail Regulations. Guidance Notes Occupational Exposure Limits EH40 EU Legislation Dangerous Preparations Directive 1999/45/EC. Regulation (EC) No 1272/2008 of the European Parliament and of the Council of 16 December 2008 on classification, labelling and packaging of substances and mixtures, amending and repealing Directives 67/548/EEC and 1999/45/EC, and amending Regulation (EC) No 1907/2006 with amendments Chemical Safety Assessment SECTION 16: OTHER INFORMATION Revision Date 18/10/11 Supersedes date 31/10/10 Risk Phrases In Full R34 R35 R20/21/22 R22 R37 R38 R41 Hazard Statements In Full H302 H312 H314 H315 H318 H332 H335 Causes burns. Causes severe burns. Harmful by inhalation, in contact with skin and if swallowed. Harmful if swallowed. Irritating to respiratory system. Irritating to skin. Risk of serious damage to eyes. Harmful if swallowed. Harmful in contact with skin. Causes severe skin burns and eye damage. Causes skin irritation. Causes serious eye damage. Harmful if inhaled. May cause respiratory irritation. Disclaimer This information relates only to the specific material designated and may not be valid for such material used in combination with any other materials or in any process. Such information is, to the best of the company's knowledge and belief, accurate and reliable as of the date indicated. However, no warranty guarantee or representation is made to its accuracy, reliability or completeness. It is the user's responsibility to satisfy himself as to the suitability of such information for his own particular use. 6 / 6