Safety Data Sheet MIGHTY BLUE DEGREASER LVOC SECTION I - IDENTIFICATION MIGHTY BLUE DEGREASER LVOC SECTION II - HAZARDOUS IDENTIFICATION

Transcription

1 Safety Data Sheet SECTION I - IDENTIFICATION Huelsmann Distributing Company, Inc. 398 S. King Oak St. Trenton, IL (618) INFOTRAC :...(800) Product Number Product Name Chemical Family CAS Number Date Prepared Revision Number Recommended Use CC MBLV Multiple 3/23/ /10/2015 Degreaser SECTION II - HAZARDOUS IDENTIFICATION GHS CLASSIFICATION: Classification Flammable Liquids Aspiration Hazard Skin Corrosion/Irritation Serious Eye Damage/Eye Irritation Category 4 Category 1 Category 2 Category 2A DANGER! GHS LABEL: Hazard Statements H227 Combustible liquid H304 H315 H319 May be fatal if swallowed and enters airways Causes skin irritation Causes serious eye irritation Page 1 of 7

2 Safety Data Sheet Precautionary Statements P210 Keep away from heat, hot surfaces, sparks,open flames, and other ignition, sources. No smoking. P264 P280 P P P P321 P331 P P P P P403 P405 P501 Wash hands thoroughly after handling. Wear protective gloves, protective clothing, eye protection and face protection. Goggles, gloves, face mask/shield and/or a separate approved breathing apparatus if required. IF SWALLOWED: Immediately call a POISON CENTER or doctor/physician. IF ON SKIN: Wash with plenty of running water and soap until all is removed. IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses if present and easy to do so - continue rinsing. Specific treatment: refer to section four, first aid or see a physician. Do NOT induce vomiting. If skin irritation occurs: get medical advice/attention. If eye irritation persists get medical advice/attention. Immediatley remove all contaminated clothing and wash them before reuse. In case of fire: Use alcohol resistant foam or CO2 to extinguish. Store in a well ventilated place. Store locked up. Dispose of contents and/or container according to state, local and federal laws. SECTION III - COMPOSITION/INFORMATION ON INGREDIENTS The precise composition of this product is proprietary information. In the event of a medical emergency, a complete disclosure will be provided to medical personnel. Component Name CAS # Component% OSHA PEL ACGIH TLV Petroleum Distillates, Hydrotreated, ppm 500 ppm Light * trade secret Alkylphenol Ethoxylate Not Established Not Established Quaternary Amine <2 SECTION IV - FIRST AID MEASURES Contact with eyes: Flush eyes for 15 minutes with clear, running water. Remove any contact lenses. Seek medical attention immediately. Can cause permanent damage. Skin contact: Inhalation: If on skin rinse well with clean water and soap. If on clothing remove the contaminated clothing immediately. Wash clothing before reuse. Seek medical attention/advice if needed. Remove victim to fresh air. If breathing difficulty seek medical attention. Administer oxygen or artificial respiration if breathing is affected or stopped. Loosen any tight Page 2 of 7

3 clothing. Safety Data Sheet Ingestion: If swallowed. Do not induce vomiting unless instructed to do so by a poison control center. Rinse mouth. Seek immediate medical attention by calling 911 and seeing a physician. Aspiration hazard. SECTION V - FIREFIGHTING MEASURES Suitable Extinguishing Media: Water fog, foam, CO2, dry chemical. Special Fire Fighting Procedures: Combustible liquid. In a fire or if heated a pressure increase may occur and the container may burst. Unusual Fire Fighting Hazards: Do not use water jet. SECTION VI - ACCIDENTAL RELEASE MEASURES Personal Precautions: Keep all sources of ignition and hot metal surfaces away from spill or release. Evacuate all unprotected personnel from the area. Environmental Precautions: Contain spill if it can be done with minimal risk. Prevent liquid from entering drains, sewers or waterways. Notify proper authorities. Methods for Cleaning Up: Use spark proof equipment. Prevent entry into waterways. Contain and collect spillage with a non combustible absorbent material like sand, vermiculite, diamatous earth. SECTION VII - HALING A STORAGE Handling and Storage: Keep containers tightly closed when not in use. Store materials to avoid sources of ignition and excessive heat. Wash thoroughly after handling. Avoid contact with eyes. EXPOSURE LIMITS: SECTION VIII - PRECAUTIONS TO CONTROL EXPOSURE / PERSONAL PROTECTION Component Name CAS # OSHA PEL ACGIH TLV Petroleum Distillates, Hydrotreated, Light ppm 500 ppm * trade secret Alkylphenol Ethoxylate Not Established Not Established Quaternary Amine Engineering Controls: Adequate local or mechanical to reduce vapor or mist to below the PEL or TLV. Showers, eye wash stations. Page 3 of 7

4 Monitoring: Safety Data Sheet Do not eat, drink or smoke in areas where this chemical is used or stored. Wash hands prior to eating, drinking or using the restroom. Any clothing or shoes which became contaminated with the product should be removed immediately and thoroughly laundered before wearing again. Personal Protective Equipment (PPE) Eye Protection: Use eye protection. Skin Protection: Impervious solvent resistent gloves. Impervious apron and work boots recommend where splashing may occur. Respiratory Protection: Use the proper respirator in areas where the chemical exposure is unknown or above the OSHA PEL or ACGIH TLV. SECTION IX - PHYSICAL A CHEMICAL PROPERTIES Appearance Blue Color Odor Mild, hydrocarbon ph@25 C Melting/Freezing Point Flashpoint Specific Gravity Soluability Insoluable in cold or hot water Auto-Ignition Temperature >220 Decomposition Temperature VOC Content Odor Threshold Boiling Range Evaporation Point 24 Flammable Limits - Upper Flammable Limits - Lower Vapor Pressure Vapor Density (Air=1) Viscosity SECTION X - STABILITY A REACTIVITY Stability: Stable, under normal conditions of storage and handling. Conditions to Avoid: Hazardous Decomposition/Byproducts: Sparks, fire, and extreme temperatures. Do not allow vapor to accumulate in low or confined areas. Hazardous Polymerization: Under normal conditions of storage and use, hazardous reactions should not occur. Page 4 of 7

5 Safety Data Sheet Polymerization Conditions to Avoid:. Incompatibilities: Strong oxidizers SECTION XI - TOXICOLOGICAL INFORMATION Likely Route of Exposure: Contact and inhalation; ingestion possible. Inhalation: Eye Contact: Skin Contact: Ingestion: Acute Toxicity Value: Chronic overexposure may result in irritation or tissue damage and an increased susceptability to respiratory illness, and permanent lung damage. Inhalation may cause irritation to the nose, throat and respiratory tract. Causes eye irritation including stinging, watering and redness which may result in corneal injury. Prolonged contact can result in chemical burns and permanent tissue damage. Repeated or prolonged contact with large amounts of this material may result in absorption through the skin to produce toxic effects. Causes irritation to the skin. Drying, cracking redness. Aspiration hazard. Can enter the lungs during swallowing or vomiting and cause chemical pneumonia and edema. Moderate to high degee of toxicity by ingestion. May be harmful or fatal if swallowed. See Health Hazards below. Chronic (Long Term) Effects: Toxicity: Component Name LD50 LC50 Petroleum Distillates, Hydrotreated, Light * trade secret Oral - rat - > 5000 mg/kg - Dermal - rabbit - >2000mg/kg Inhalation - rat - >5 mg/l / 4 h Alkylphenol Ethoxylate Quaternary Amine Oral - Rat ,980 mg/kg; Dermal - Rabbit - 2,000-2,991 Inhalation - Rat - 4 h mg/l Reproductive Effects Page 5 of 7

6 Teratogenicity Mutagenicity Embryotoxicity Safety Data Sheet Sensitization to Product Synergistic Products Not Applicable Carcinogenicity SECTION XII - ECOLOGICAL INFORMATION Ecotoxicity: Chronic NOEL.48mg/l. Daphnia after 21 days of exposure. Mobility: Information not available. Degradability: Information not available. BioAccumulation: Information not available. Follow federal, state and local guidelines. SECTION XIII - WASTE DISPOSAL CONSIDERATIONS SECTION XIV - TRANSPORT INFORMATION DOT SHIPPING INFORMATION Proper Shipping Name: Combustible Liquid, NOS Contains: Distillates, hydrotreated light Hazard Class and Label: 3 Identification Number: UN 1993 Packaging Group: III Other Shipping Info: SECTION XV - REGULATORY INFORMATION TSCA STATUS:... The components of this product are listed on the TSCA Inventory SARA TITLE III SECTION 302/304 EXTREMELY HAZARDOUS SUBSTANCE: No chemicals in this material are subject to the reporting requirements. Page 6 of 7

7 Safety Data Sheet SARA TITLE III SECTION 311/312 HAZARD CATEGORIZATION: Acute X Chronic N/A Fire X Pressure Reactive SARA TITLE III SECTION 313 SUPPLIER INFORMATION: No chemicals in this material are subject to the reporting requirements. CERCLA SECTION 102(a) HAZARDOUS SUBSTANCE: No chemicals in this material are subject to the reporting requirements. CALIFORNIA PROPOSITION 65: No chemicals in this material are subject to the reporting requirements. SECTION XVI - OTHER INFORMATION HMIS Health:... 1 HMIS Flammability:... 2 HMIS Reactivity:... 0 Additional: Specification Information Department issuing data sheet: address: Training necessary: carchem2005@yahoo.com Disclaimer: Huelsmann Distributing Company, Inc. cannot anticipate all conditions under which this information and its product or the products of other manufacturers in combination with its product, may be used. It is the users responsibility to ensure safe conditions for handling, storage and disposal of the product, and assume liability for loss, injury, damage or expense due to improper use. The information provided in this safety data sheet ha been obtained from resources assumed to be reliable. We provide no warrenties, either expressed or implied and assume no responsibility for the accuracy or completeness of the data contained herein. This information is offered for your information, consideration and investigation. You should satisfy yourself that you have all current data relevant for your use. Page 7 of 7

8