SAFETY DATA SHEET SANSOL

Transcription

1 Section 1: IDENTIFICATION Recommended Use: Heavy duty foaming bathroom disinfectant / cleaner. Product Code: (12 1L), a (3x5L) Whiteley Industrial A division of Whiteley Corporation Pty Ltd (A.C.N ) Postal Address: P. O. Box 1076 North Sydney NSW 2059 Telephone Number: (02) Facsimile: (02) Web: Emergency Telephone Number: Poisons Information Centre (National) Distributed in New Zealand by: Whiteley Corporation NZ Limited Address: PO Box Otahuhu, Auckland, New Zealand 1640 Telephone Number: , Emergency Telephone Number: New Zealand Poisons Centre 0800 POISON or GHS Classification Eye Irritation (Category 2) Skin Irritation (Category 2) Section 2: HAZARDS Signal Word WARNING Hazard Statements H315 Causes skin irritation H319 Causes serious eye irritation Precautionary Statements P264 Wash hands thoroughly after using P280 Wear protective gloves and eye protection. Response Statements P302 + IF ON SKIN: Wash with plenty of soap and water. P352 P305 + IF IN EYES: Rinse cautiously with water for several minutes. Remove contact P351 + lenses, if present and easy to do. Continue rinsing. P338 P332 + If skin irritation occurs: Get medical advice/attention. P313 P337 + If eye irritation persists: Get medical advice/attention. P313 Issue No. 2 GHS Page 1 of 6

2 P362 Take off contaminated clothing and wash before reuse. Storage Statements None Disposal Statements None HSNO Classifications 6.3A Substances that are irritating to the skin 6.4A Substances that are irritating to the eye Section 3: COMPOSITION INFORMATION Ingredient CAS No Proportion Glycolic Acid <10% Zinc Chloride <10% Ingredients deemed not to be hazardous Not applicable To 100% Section 4: FIRST AID Eye (Contact) Skin (Contact) Inhalation(Breathing) Ingestion (Swallowing) Advice to Doctor First Aid Facilities Additional Information Hold eyelids apart and flush the eye continuously with running water. Immediately call a Poison Centre or doctor/physician. Remove contaminated clothing and flush skin and hair with running water. If skin irritation occurs seek medical advice. Wash contaminated clothing before reuse. Remove to fresh air. DO NOT induce vomiting. Give water to drink if conscious. For advice, contact a Poisons Information Centre (Phone ) or a doctor/physician. Treat symptomatically. Ensure an eye wash and safety shower are available and ready for use. No aggravated medical conditions are known to be caused by exposure to this product. Section 5: FIREFIGHTING MEASURE Suitable Extinguishing Media Use water fog (or if unavailable fine water spray), dry chemical, carbon dioxide or alcohol stable foam. Hazards From Combustion Products Carbon dioxide and carbon monoxide may be produced in the case of fire or during thermal decomposition. Issue No. 2 GHS Page 2 of 6

3 Precautions For Fire Fighters and Special Protective Equipment Additional Information Firefighters must wear full protective clothing including self-contained breathing apparatus and chemical splash suit. Remove from the vicinity containers not involved in the fire. Hazchem Code Not applicable. Section 6: ACCIDENTAL RELEASE MEASURES Emergency Procedure SAA/SNZ HB76: Dangerous Goods Initial Emergency Response Guide Not applicable. Spills / Clean up Precautions for Safe Handling Conditions for Safe Storage Clean up personnel should wear full protective clothing. Restrict access until completion of clean up. Then ensure adequate ventilation. Stop leak if safe to do so. Contain spill with absorbent material, such as towelling, sand, vermiculite or other inert material. Prevent spill entering stormwater drains or waterways. Collect and dispose of clean up material according to local regulations. Wash away remnants with copious amounts of cold water to sewer. Clean area by working from the periphery to the centre of spill or from the edge of the room to the centre. Section 7: HANDLING AND STORAGE Contact Whiteley Corporation sales representative for advice when using this product for any application other than that outlined on the label or technical bulletin. Any non-intended or non-authorised use of this product may result in personal injury or damage to equipment. Store product in original container. Wash thoroughly after handling product. Store in a cool, dry, well ventilated area. Keep container tightly sealed. Store below 30 C. Section 8: EXPOSURE CONTROL/PERSONAL PROTECTION National Exposure Standards Source: National Exposure Standards for Atmospheric Contaminants in the Occupational Environment [NOHSC:1003] & New Zealand Workplace Exposure Standards Ingredient CAS No ES-TWA ES-STEL Biological Limit Values Engineering Controls Personal Protective Equipment Use only in a well ventilated area. Eye/face protection Safety glasses / face shield / chemical resistant goggles should be worn to prevent eye contact. Skin protection Use Nitrile gloves or similar to prevent skin contact. Respiratory protection Respirator is not usually necessary but if required use a half face filter respirator suitable for organic vapours. Issue No. 2 GHS Page 3 of 6

4 Section 9: PHYSICAL AND CHEMICAL PROPERTIES Appearance Clear pale yellow Odour Characteristic liquid Odour Threshold ph Freezing Point Approx. 0⁰ C Initial Boiling Point Approx. 100⁰ C Boiling Range Flash point Evaporation Rate Flammability Upper flammability limit Lower flammability limit Vapour Pressure Vapour Density Relative Density Solubility Completely miscible with water Partition Coefficient: n-octanol/water Autoignition temperature Decomposition temperature Viscosity Approx. 10 cps Section 10: STABILITY AND REACTIVITY Chemical Stability Conditions to avoid Incompatible materials Hazardous decomposition products Hazardous reactions Acute toxicity Skin corrosion/ irritation Serious eye damage/ irritation Respiratory or skin sensitisation Product is stable and will not undergo any hazardous reactions under normal conditions of use and storage. Avoid high temperatures (store below 30 C). None known. Do not mix with other chemicals. None known. None known. Section 11: TOXICOLOGICAL INFORMATION Zinc Chloride: LD mg/kg (mouse, oral) Glycolic Acid: LD mg/kg (rat, oral) Product causes irritation, pain and reddening on skin contact Product causes irritation, pain and reddening on eye contact. Issue No. 2 GHS Page 4 of 6

5 Germ Cell Mutagenicity Carcinogenicity Reproductive toxicity Specific Target Organ Toxicity Single Exposure Specific Target Organ Toxicity Repeated Exposure Aspiration Hazard Section 12: ECOLOGICAL INFORMATION Ecotoxicity Persistence and degradability Bioaccumulative potential Mobility in soil Other adverse effects Section 13: DISPOSAL CONSIDERATIONS Disposal method Special precautions Disposal to sewer is normally recommended with copious amounts of water. Refer to State/Territory Land Waste Management Authorities if applicable. Containers are recyclable and can be disposed of by a licensed waste contractor. Containers can be disposed of to general waste or rinsed thoroughly and recycled. Suitable for incineration by approved agent. Section 14: TRANSPORT INFORMATION Not classified as Dangerous Goods by the criteria of the Australian Dangerous Goods Code (ADG Code). UN Number Not applicable. UN Proper Shipping Name Not applicable. Class and subsidiary risk Not applicable. Packing Group Not applicable. Special precautions for Not applicable. user Hazchem Code Not applicable. Issue No. 2 GHS Page 5 of 6

6 Poisons Schedule (SUSDP): Not applicable. HSNO Approval Code: HSR Section 15: REGULATORY INFORMATION All ingredients are listed in the Australia Inventory of Chemical Substances (AICS). This document has been produced in accordance with the requirements of the Globally Harmonised System of Classification and Labelling. Section 16: OTHER INFORMATION Date of preparation: 16 th March 2018 This document remains property of Whiteley Corporation Pty Ltd. Alterations are not permitted without prior written authorisation from Whiteley Corporation Pty Ltd. Issue No. 2 GHS Page 6 of 6