Weaver Leather LLC SAFETY DATA SHEET. This SDS complies with REACH 1907/2006 and 2001/58/EC, GHS, OSHA 29CFR

Transcription

1 SAFETY DATA SHEET This SDS complies with REACH 1907/2006 and 2001/58/EC, GHS, OSHA 29CFR Section 1: Chemical Product and Company Identification DISTRIBUTOR S NAME: EMERGENCY TELEPHONE Weaver Leather LLC County Rd 201 Mt. Hope, OH DATE PREPARED: July 29, 2013 PRODUCT NAME: FORMULA: PRODUCT USE: HONEY HOOVES Preparation/Mixture Horse hoof treatment Section 2: Hazards Identification Regulation (EC) No 1272/2008 GHS Hazard Class Not Applicable Signal word: Hazard Statement: Precautionary Statements: Prevention No Precautionary statement Response No Precautionary statement Storage No Precautionary statement Disposal No Precautionary statement HAZARD CLASSIFICATION: FIRE AND EXPLOSION: POTENTIAL HEALTH EFFECTS: INGESTION: INHALATION: SKIN CONTACT: EYE CONTACT: OTHER: CHRONIC EFFECTS OF OVEREXPOSURE: APPEARANCE: Not classified as hazardous based on IATA, IMO and DOT. Not considered flammable or combustible, but this product will burn if involved in a fire. <1% of mixture consists of ingredients of unknown acute toxicity Very hazardous if ingested Very hazardous in case of ingestion. PINE TAR May cause slight irritation Eye irritation may result Brown solid NFPA Rating: Component Health Flammability Reactivity Special (Blue) (Red) (Yellow) (White) Honey Hooves SDS Page 1 of 6

2 Section 3: Composition, Information on Ingredients PRODUCT COMPOSITION APPRX % ACGIH TLV OSHA PEL NIOSH REL CAS NO. EINECS/ ELINCS DANGER SYMBOL RISK PHRASE DSL CANADA Tea tree oil < N/N Y Y Pine tar > Y Y Beeswax > Y Y Microcrystalline > Y Y Coconut oil < Y Y Trade Secret (TS) Some items on this MSDS may be designated as trade secrets. Bonafide requests for disclosure of trade secret information to medical personnel must be made in accordance with the provisions contained in 29 CFR I The full text for all R-Phrases is shown in Section 16. Section 4: First Aid Measures TSCA INHALATION: SKIN CONTACT: EYE CONTACT: INGESTION: Remove to fresh air. If not breathing, provide CPR (cardio pulmonary resuscitation). Get immediate medical attention. Immediately flush skin with plenty of soap and water for at least 15 minutes. Remove contaminated clothing. Immediately flush eyes with plenty of water for at least 15 minutes. Get immediate medical attention. If swallowed do not induce vomiting, give large quantities of water to drink. Never give anything to an unconscious person. Get immediate medical attention. Section 5: Fire-fighting Measures FLASH POINT: FLAMMABLE LIMITS IN AIR (% by vol): EXTINGUISHING MEDIA: SPECIAL FIREFIGHTING PROCEDURES: UNUSUAL FIRE AND EXPLOSION HAZARDS: Not applicable Not measured Foam, Dry Chemical Powder, or Carbon Dioxide Emits toxic fumes under fire conditions. Section 6: Accidental Release Measures ACTION TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED: Wear proper protective equipment as specified in Section 8: Exposure Controls/Personal Protection. DISPOSAL METHOD: Disposal in municipal trash may be acceptable. Dispose of this container according to local, state, and federal laws in your country. Section 7: Handling and Storage PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE: Store upright in a cool, dry place. Keep container closed when not in use. Keep away from heat and flame. Wash hands after handling this material. Follow all applicable local regulations for handling and storage. INFORMATION ON EMPTIED CONTAINER Dispose of this container according to local, state, and federal laws in your country. SPECIFIC USES: Horse hoof treatment. SDS Page 2 of 6

3 Section 8: Exposure Controls/Personal Protection EXPOSURE GUIDELINES EXPOSURE LIMITS Reference Section 2 VENTILATION: Use in areas of adequate ventilation. SPECIAL VENTILATION CONTROLS: Special ventilation precautions not required RESPIRATORY PROTECTION: No respiratory protection normally required. In case of mist, spray or aerosol exposure, wear suitable personal respiratory equipment. PROTECTIVE GLOVES: Neoprene or nitrile rubber gloves are recommended. EYE PROTECTION: No special eye protection is normally required. Where splashing is possible, wear safety glasses, goggles or face shield. SKIN PROTECTION: Suitable protective clothing to prevent skin contact OTHER EQUIPMENT: Make safety shower, eyewash stations, and hand washing equipment available in the work area. WORK/HYGIENE PRACTICES: Provide good personal hygiene after handling. Avoid contact with eyes. Wash hands after handling. Section 9: Physical and Chemical Properties APPEARANCE - COLOR: PHYSICAL STATE: ODOR: Brown Solid paste Pine tar PRODUCT CRITERIA PRODUCT CRITERIA ODOR THRESHOLD PH FLASH POINT: LOWER EXPLOSIVE LIMIT; UPPER EXPLOSIVE LIMIT FLAMMABILITY (Solid, gas) EXPLOSIVE PROPERTIES OXIDIZING PROPERTIES SPECIFIC GRAVITY (@25 o C): EVAPORATION RATE: % VOLATILE by VOLUME PARTITION COEFFICIENT AUTO IGNITION TEMPERATURE DECOMPOSITION TEMPERATURE BOILING POINT: MELTING POINT: VAPOR PRESSURE VAPOR DENSITY (AIR = 1) SOLUBILITY IN WATER: WATER SOLUBILITY IN THE SOLVENT FREEZING POINT: VISCOSITY VOC CONTENT Section 10: Stability and Reactivity STABILITY: CONDITIONS TO AVOID: INCOMPATIBILITY (MATERIALS TO AVOID): HAZARDOUS DECOMPOSITION PRODUCTS: HAZARDOUS POLYMERIZATION: Stable under normal conditions of use. Avoid heat or flames. Will not occur SDS Page 3 of 6

4 Section 11: Toxicological Information GHS Required Criteria Toxicity Criteria Toxicity Information Comments Chemical Constituent Acute Toxicity LD50 (Oral/Rat): 1682 mg/kg Tea tree oil LD50 (Dermal/Rabbit): 500 mg/kg Tea tree oil Skin Corrosion/Irritation Serious Eye Damage / Eye Irritation Respiratory or Skin Sensitization Germ Cell Mutagenicity Carcinogenicity NTP IARC OSHA Reproductive Toxicity STOST -- Single Exposure STOST Repeated Exposure Aspiration Hazard STOST = Specific Target Organ Systemic Toxicity OTHER INFORMATION: Only selected Registry of Toxic Effects of Chemical Substances (RTECS) data is presented here. See actual entry in RTECS for complete information. Section 12: Ecological Information Chemical BIODEGRADATION: BIOACCUMULATION: ECO TOXICITY: MOBILITY: Note: No environmental hazards were identified based on a review of available data for the ingredients in this product. Not all of the ingredients have been tested for Ecotoxicity. Section 13: Disposal Considerations WASTE FROM RESIDUES / UNUSED PRODUCTS: Follow the waste disposal requirements of your country, state, or local authorities. CONTAMINATED PACKAGING: Contaminated packaging material should be disposed of as stated above for residues and unused product. RINSATE: Do not dispose of rinse water containing product in a sanitary sewer system or storm water drainage system. Section 14: Transport Information DOT TRANSPORT: ADR = International Carriage of Dangerous Goods by Road RAIL TRANSPORT: Not Regulated Not Regulated Not Regulated SEA TRANSPORT: IMDG Not Regulated AIR TRANSPORT: IATA/ICAO Not Regulated SDS Page 4 of 6

5 Section 15: Regulatory Information Directive 67/548/EEC LABEL FOR SUPPLY: IRRITANT RISK PHRASES: R-Phrase: R36 Irritating to Eyes R38 Irritating to Skin S-Phrase: S24 Avoid contact with Skin S25 Avoid contact with Eyes TOXIC SUBSTANCES CONTROL ACT (TSCA) STATUS: This product is in compliance with rules, regulations, and orders of TSCA. Inventory. All components are listed on the TSCA SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF 1986 (SARA) TITLE III SECTION 313 SUPPLIER NOTIFICATION: This regulation requires submission of annual reports of toxic chemical(s) that appear in section 313 of the Emergency Planning and Community Right To Know Act of 1986 and 40 CFR 372. This information must be included in all MSDS s that are copied and distributed for the material. The Section 313 toxic chemicals contained in this product are: CALIFORNIA PROPOSITION 65: This regulation requires a warning for California Proposition 65 chemical(s) under the statute. The California proposition 65 chemical(s) contained in this product are: STATE RIGHT-TO-KNOW TOXIC SUBSTANCE OR HAZARDOUS SUBSTANCE LIST: Florida Toxic Substance(s): Massachusetts s hazardous substance(s): Pennsylvania hazardous substance code(s): New Jersey Illinois Michigan CANADA: This MSDS/SDS will be non compliant 3 years after the issue date. This MSDS contains all of the information required by the Controlled Products Regulations (CPR). WHMIS-INFORMATION: This product has been classified in accordance with the hazard criteria of the Controlled Products Regulations (CPR), SOR/88-66, Current to February 20, The classes of controlled products listed in the CPR, Section 32, Part IV, have been reviewed and based on Professional Judgment this product has been determined to not be WHMIS controlled. EUROPEAN UNION: This product has been reviewed for compliance with the following European Community Directives: REACH 1907/2006; Directive 67/548/EEC, Regulation (EC) No 1272/2008 on classification, labeling and packaging (CLP) of substances and mixtures. Section 16: Other Information European Community Hazards Identification: R: S: Danger Symbol(s): Revision Comments: Updated from May 14, 2013 Revision Number: 0 Information Sources: RTECS, REACH, OSHA 29CFR SDS Page 5 of 6

6 Weaver Leather LLC believes the information contained herein is accurate; however, Weaver Leather LLC makes no guarantees with respect to such accuracy and assumes no liability in connection with the use of the information contained herein which is not intended to be and should not be construed as legal advice or as insuring compliance with any federal, state or local laws or regulations. Any party using this product should review all such laws, rules, or regulations prior to use, including but not limited to US and Canada Federal, Provincial and State regulations. NO WARRANTY IS MADE, EXPRESS OR IMPLIED, OF MERCHANTABILITY, FITNESS FOR A PARTICULAR PURPOSE, OR OTHERWISE. MSDS AUTHORED BY: SDS Page 6 of 6