MATERIAL SAFETY DATA SHEET Date Revised: 12/31/08 Page: 1 HI-BOND CLEAR TABLE TOP EPOXY MSDS Number:

Transcription

1 MATERIAL SAFETY DATA SHEET Date Revised: 12/31/08 Page: 1 HI-BOND CLEAR TABLE TOP EPOXY MSDS Number: SECTION 1. CHEMICAL PRODUCT AND COMPANY IDENTIFICATION Material Identity Product Name: HI-BOND CLEAR TABLE TOP EPOXY Product Numbers: , 1350, 1360 Company Emergency Telephone Numbers: Fibre Glass-Evercoat CHEMTREC: a Division of Illinois Tool Works Inc Cornell Road Cincinnati, Ohio USA Phone: Prepared By: Safety Department The percent by weight composition data given in Section II is NOT SPECIFICATION, but is based on `target' formula values for each ingredient in the product. The data is presented as ranges for low hazard ingredients and single point values for ingredients of regulatory concern. Actual batch concentrations will vary within limits consistent with separately established product specifications. SECTION II INGREDIENTS - - OSHA CAS No. * Common Name: CHEMICAL IDENTITY Phenol, 4,4 '-(1- methylethylidene) bis-polymer with (chloromethyl)oxirane Bisphenol A Diglycidy Ether Polymer EXPOSURE LIMITS CARCINOGEN STATUS ACGIH OSHA TWA STEL PEL STEL MFR IARC NTP OSHA NE NE NE NE NE NR NR NR NE = Not Established NR = Not Reviewed * = OSHA Hazardous Ingredient SECTION III HAZARD IDENTIFICATION Emergency Overti v iew: Can cause skin irritation, eye irritation, and allergic skin reaction. Primary Route( s) of Entry: Dermal. SECTION IV FIRST AID MEASURES Ingestion: : Do not induce vomiting unless directed to do so by medical persormel. Never give anything by mouth to an unconscious person. Seek immediate medical attention. 1

2 Skin: Skin: Immediately wash with soap and water. Remove contaminated clothing and launder before reuse. Destroy contaminated shoes. Seek immediate medical attention. Inhalation: Remove to fresh air. Seek immediate medical attention. Eyes: Immediately flush eyes with water for at least 15 minutes. Seek immediate medical attention. Overexposure Effects: Can cause skin irritation, eye irritation, and allergic skin reaction. Medical Conditions Aggravated by Exposure: Allergy, eczema or skin condition. Additional Information: Promptly remove wet contaminatednon-imperti v ious clothing. Wash before reuse. SECTION V FIRE FIGHTING MEASURES Flash Point: 490 F (254 C) Flash Point Method Used: Closed Cup Fire Fighting Extinguishing Media: Carbon dioxide, foam, dry chemical, water spray. Fire Fighting Equipment: Use self-contained breathing apparatus. Fire and Explosion Hazards: Decomposition and combustion products may be toxic. SECTION VI ACCIDENTAL RELEASE MEASURES Accidental Release Measures: Avoid all personal contact. Take up with absorbent material. Shovel into closable containers. Flush contaminated area with water. SECTION VII HANDLING AND STORAGE Signal Word: Warring! Precautions: Can cause skin irritation, eye irritation, and allergic skin reaction. Avoid contact with eyes, skin, and clothing. Wash thoroughly after handling. Storage Information: Store in cool, dry area in sealed containers. Keep containers closed to prevent moisture absorption and contamination. 2

3 SECTION VIII EXPOSURE CONTROLS / PERSONAL PROTECTION Personal Protective Equipment: Wear appropriate equipment to prevent eye or skin contact. Use of barrier cream recommended. Skin Protection: Wear impervious gloves. Respiratory Protection: Organic chemical cartridge respirator, if needed. Eye Protection: Wear splash-proof chemical goggles. Engineering Controls: Good general mechanical ventilation and local exhaust. SECTION IX PHYSICAL AND CHEMICAL PROPERTIES Color: Odor: Physical State: Solubility- in Water: Vapor Pressure: Specific Gravity: Boiling Point: Decomposition Temperature: Percent Volatile: Nil. Clear Slight Liquid Insoluble - 1 mmhg at 180 C (356 F) at 20 C(68 F) at 25 C (77 F) > 200 C (> 392 F) > 200 C (> 392 F) SECTION X STABILITY AND REACTIVITY Conditions to Avoid: Avoid strong acids or bases in bulk and elevated temperatures. Stability: Stable. Incompatibility: Strong oxidizing agents. Hazardous Decomposition Products: Carbon monoxide, carbon dioxide, aldehydes. Hazardous Polymerization: Will not occur. SECTION XI TOXICOLOGICAL INFORMATION Acute Oral Effects (LD50): (Rat) > 5,000 mg/kg. Acute Dermal Toxicity (LD50): (Rabbit) > 6000 mg/kg. Sensitization: Moderate sensitizer. 3

4 Carcinogenicity: Based on several dermal studies in mice, IARC had concluded in 1999 that diglycidyl ether of bisphenol A is not classifiable as a human carcinogen (Group 3) and has limited evidence of carcinogenicity in animals. Skin Irritation: (Rabbit) Moderate irritation. Eye Irritation: (Rabbit) Slight Reproduction: For diglycidyl ether of bisphenol A-There were no treatmentrelated histologic changes noted nor effects on reproductive performance in rats at any oral dose tested. Teratogenicity: For diglycidyl ether of bisphenol A-No adverse effects on embryonic or fetal development was observed in rabbits after dermal exposure. Mutagenicity: For diglycidyl ether of bisphenol A-In vitro tests showed mutageruc effects which were not observed with in vivo tests. Sub-C111oMc: Diglycidyl ether of bisphenol A, applied to the skin of rats five times per week for approximately 13 weeks, caused no apparent systemic toxicity with the exception of decreased body weight and body weight gain. SECTION XII ECOLOGICAL INFORMATION Biodegradability: (Modified Sturm method): -12% Fish Toxicity: Rainbow-Trout (96111.): LC mg/1. Zebra Fish (96111.): LC mg/1. Invertebrate Toxicity: Dapluria Toxicity (24111.): EC mg/1. SECTION XIII DISPOSAL CONSIDERATIONS --- Waste Disposal Method: Dispose in accordance with federal, state and local regulations. SECTION XIV TRANSPORT INFORMATION Department of Transportation: Not regulated as a hazardous material by the U.S. Dept. of Transportation (DOT) 49 CFR SECTION XV REGULATORY INFORMATION US Federal Regulations: Occupational Safety and Health Act (OSHA): This Material Safety Data Sheet (MSDS) has been prepared in compliance with the federal OSHA Hazard Communication Standard 29 CFR This product is considered to be a hazarous chemical under that standard. Resource Conservation and Recovery Act (RCRA): Not a hazardous waste under RCRA (40 CFR 261). 4

5 SARA Title III: Section 313 Toxic Chemical List (TCL): This product does not contain any chemicals for routine armual toxic chemical release reporting under Section 313 (40 CFR 372). TSCA Section 8(b) -Inventory Status: All chemical components of this product are in compliance with TSCA inventory requirements. TSCA Section 12(b) -Export Notification: This product does not contain any chemical(s) that are subject to a Section 12(b) export notification. International Regulations: Canadian Inventory Status: All components included on the Domestic Substances List (DSL). State Regulations: California Proposition 65: This product does not contain any chemicals currently on the California list of Known Carcinogens and Reproductive Toxins. New Jersey Right-to-Know: The following is required composition information: Chemical Name: Phenol, 14'-(1-methylethylidene)bis-, polymer with (chloromethyl)oxirane Common Name: Bisphenol A Diglycidyl Ether Polymer CAS Number: Pemrsyivania Right-to-Know: The following is required composition information: Chemical Name: Phenol, 14'-(1-methylethylidene)bis-, polymer with (chloromethyl)oxirane Common Name: Bisphenol A Diglycidyl Ether Polymer CAS Number: Comment: Not on Permsy h v ania Hazardous Substance List DISCLAIMER AND LIMITATION OF LIABILITY Additional Information may be obtained by calling the Evercoat MSDS Hotline at NOTICE: The information accumulated herein is believed to be correct as of the date issued from sources, which are believed to be accurate and reliable. Since it is not possible to anticipate all circumstances of use, recipients are advised to confirm, in advance of need, that the information is current, applicable and suitable to their circumstances. 5