SAFETY DATA SHEET DELIMER NON-CORROSIVE LIME SCALE REMOVER Section 1. Chemical product and company identification Product name Recommended use and restrictions DELIMER NON-CORROSIVE LIME SCALE REMOVER Delimer Use only for the purpose on the product label. Product dilution information 1.5 oz / 32. oz Supplier's information Code Date of issue Section 2. Hazards identification GHS Classification GHS label elements Kay Chemical Company 83 Capital Drive Greensboro NC 2749 1-8-529-5458 (Customer Service) 912272-5 23 Oct 213 EMERGENCY HEALTH INFORMATION 1-877-231-2615 Outside United States and Canada CALL -952-853-1713 SERIOUS EYE DAMAGE/ EYE IRRITATION - Category 2A SERIOUS EYE DAMAGE/ EYE IRRITATION - Category 2B Signal word Symbol Warning Warning Hazard statements Causes serious eye irritation. Precautionary statements Prevention Response Storage Disposal Other hazards Wear eye or face protection. Do not mix with bleach or other chlorinated products - will cause chlorine gas. Wash hands thoroughly after handling. IF IN EYES Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. If eye irritation persists Get medical attention. No other specific measures identified. See section 13 for waste disposal information. None known. Causes eye irritation. Wash hands thoroughly after handling. IF IN EYES Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. If eye irritation persists Get medical attention. No other specific measures identified. See section 13 for waste disposal information. None known. Page 1/7
DELIMER NON-CORROSIVE LIME SCALE REMOVER 23 Oct 213 Section 3. Composition/information on ingredients Substance/mixture Hazardous ingredients Hazardous ingredients Mixture Concentration Range (%) Concentration Range (%) CAS number CITRIC ACID >5 77-92-9 CAS number CITRIC ACID 1-5 77-92-9 Section 4. First aid measures Eye contact Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. Get medical attention if irritation persists. Skin contact No known effect after skin contact. Rinse with water for a few minutes. Inhalation No special measures required. Treat symptomatically. Ingestion Get medical attention if symptoms occur. Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. Get medical attention if irritation persists. No known effect after skin contact. Rinse with water for a few minutes. No special measures required. Treat symptomatically. Get medical attention if symptoms occur. Protection of firstaiders No action shall be taken involving any personal risk or without suitable training. It may be dangerous to the person providing aid to give mouth-to-mouth resuscitation. Notes to physician Treat symptomatically. Contact poison treatment specialist immediately if large quantities have been ingested or inhaled. See toxicological information (section 11) Section 5. Fire-fighting measures Suitable fire extinguishing media Specific hazards arising from the chemical Hazardous thermal decomposition products Specific fire-fighting methods Special protective equipment for fire-fighters Use water spray, fog or foam. No specific fire or explosion hazard. Section 6. Accidental release measures Decomposition products may include the following materials carbon dioxide carbon monoxide Promptly isolate the scene by removing all persons from the vicinity of the incident if there is a fire. No action shall be taken involving any personal risk or without suitable training. Fire-fighters should wear appropriate protective equipment and self-contained breathing apparatus (SCBA) with a full face-piece operated in positive pressure mode. Page 2/7
DELIMER NON-CORROSIVE LIME SCALE REMOVER 23 Oct 213 Section 6. Accidental release measures Personal precautions Environmental precautions Methods for cleaning up Handling Storage Use personal protective equipment as required. Avoid contact of large amounts of spilled material and runoff with soil and surface waterways. Collect spillage. Use a water rinse for final cleanup. Section 7. Handling and storage Control parameters Appropriate engineering controls Personal protection Eye protection Hand protection Skin protection Respiratory protection Hygiene measures Use personal protective equipment as required. Avoid contact of large amounts of spilled material and runoff with soil and surface waterways. Use a water rinse for final clean-up. Avoid contact with eyes, skin and clothing. Do Avoid contact with eyes, skin and clothing. not mix with bleach or other chlorinated products - Wash thoroughly after handling. will cause chlorine gas. Wash thoroughly after handling. Keep out of reach of children. Keep container Keep out of reach of children. Keep tightly closed. container tightly closed. Store between the following temperatures and 5 C Section 8. Exposure controls/personal protection Ingredient name None. Good general ventilation should be sufficient to control worker exposure to airborne contaminants. Wear eye protection. No protective equipment is needed under normal use conditions. No protective equipment is needed under normal use conditions. A respirator is not needed under normal and intended conditions of product use. Exposure limits Good general ventilation should be sufficient to control worker exposure to airborne contaminants. No protective equipment is needed under normal use conditions. No protective equipment is needed under normal use conditions. No protective equipment is needed under normal use conditions. A respirator is not needed under normal and intended conditions of product use. Wash hands, forearms and face thoroughly after handling chemical products, before eating, smoking and using the lavatory and at the end of the working period. Appropriate techniques should be used to remove potentially contaminated clothing. Wash contaminated clothing before reusing. Section 9. Physical and chemical properties Page 3/7
DELIMER NON-CORROSIVE LIME SCALE REMOVER 23 Oct 213 Section 9. Physical and chemical properties Physical state Color Odor ph Flash point Explosion limits (solid, gas) Melting point Boiling point Evaporation rate (butyl acetate = 1) Vapor pressure Vapor density Relative density Solubility Partition coefficient n-octanol/water Auto-ignition temperature Decomposition temperature Odor threshold Viscosity Stability Possibility of hazardous reactions Solid White Hazardous decomposition products Odorless Not applicable > 1 C Product does not support combustion. 1.44 to 1.64 (Water = 1) Easily soluble in the following materials cold water. Conditions to avoid Materials to avoid Kinematic (room temperature) cm 2 /s ( cst) Section 1. Stability and reactivity Section 11. Toxicological information Route of exposure Liquid. Colorless Odorless 2.3 > 1 C The product is stable. Under normal conditions of storage and use, hazardous reactions will not occur. Reactive or incompatible with the following materials alkalis. Do not mix with bleach or other chlorinated products - will cause chlorine gas. Slightly reactive or incompatible with the following materials metals. Under normal conditions of storage and use, hazardous decomposition products should not be produced. Skin contact, Eye contact, Ingestion Page 4/7
DELIMER NON-CORROSIVE LIME SCALE REMOVER 23 Oct 213 Section 11. Toxicological information Symptoms Eye contact Adverse symptoms may include the following pain or irritation watering redness Skin contact Inhalation Ingestion Acute toxicity Eye contact Skin contact Inhalation Ingestion Toxicity data Product/ingredient name citric acid LD5 Dermal Rat >2 mg/kg LD5 Oral Rat 117 mg/kg Chronic toxicity Carcinogenicity Mutagenicity Teratogenicity Developmental effects Fertility effects Other adverse effects Causes serious eye irritation. Section 12. Ecological information Adverse symptoms may include the following irritation watering redness Causes eye irritation. No known significant effects or critical hazards. No known significant effects or critical hazards. No known significant effects or critical hazards. Ecotoxicity Aquatic and terrestrial toxicity Product/ingredient name Result Species Exposure citric acid Acute LC5 >1 mg/l Fish 96 hours Disposal methods Section 13. Disposal considerations Diluted product can be flushed to sanitary sewer. Discard empty container in trash. Diluted product can be flushed to sanitary sewer. Discard empty container in trash. Page 5/7
DELIMER NON-CORROSIVE LIME SCALE REMOVER 23 Oct 213 Section 14. Transport information Certain shipping modes or package sizes may have exceptions from the transport regulations. The classification provided may not reflect those exceptions and may not apply to all shipping modes or package sizes. DOT DOT Classification IMO/IMDG IMO/IMDG Classification Not intended for transport. Not regulated. Not regulated. For transport in bulk, see shipping documents for specific transportation information. Section 15. Regulatory information U.S. Federal regulations TSCA 8(b) inventory All components are listed or exempted. SARA 32/34/311/312 extremely hazardous substances No listed substance SARA 32/34 emergency planning and notification No listed substance SARA 313 Product name CAS number Concentration Form R - Reporting requirements California Prop. 65 No listed substance No listed substance Section 16. Other information Hazardous Material Information System (U.S.A.) Health Physical hazards 2 Health Physical hazards 1 National Fire Protection Association (U.S.A.) Health 2 Instability/Reactivity Health 1 Instability/Reactivity Special Special Date of issue Prepared by Notice to reader 23 Oct 213 Regulatory Affairs 1-8-352-5326 Page 6/7
DELIMER NON-CORROSIVE LIME SCALE REMOVER 23 Oct 213 Section 16. Other information The above information is believed to be correct with respect to the formula used to manufacture the product in the country of origin. As data, standards, and regulations change, and conditions of use and handling are beyond our control, NO WARRANTY, EXPRESS OR IMPLIED, IS MADE AS TO THE COMPLETENESS OR CONTINUING ACCURACY OF THIS INFORMATION. Page 7/7