MSDS Name: Greaseless Lubricant Manufacturer Name: Fastenal Components: A00384 : I-Chem Greaseless Lubricant #ICA384 : Greaseless Lubricant Amrep, Inc. NFPA HMIS I-Chem Greaseless Lubricant #ICA384 Manufacturer MSDS Number: A00384 2 2 0 HEALTH 2 FIRE 2 REACTIVITY 0 PPE B SECTION 1 : Chemical Product and Company Identification MSDS Name: I-Chem Greaseless Lubricant #ICA384 Manufacturer Name:Amrep, Inc. Address: 990 Industrial Park Drive Marietta, GA 30062 EMERGENCY RESPONSE NUMBER: 1 (800) 255-3924 Business Phone:(770) 422-2071 For information in North America, call: (770) 422-2071 Manufacturer MSDS Revision Date: December 10, 2007 Supersedes: 11/23/04 Revision - 2 NFPA Health: 2 Flammability: 2 Other: HMIS Health Hazard: 2 Fire Hazard: 2 Personal Protection: B Prepared By: IB/TR DOT Hazard Classification: ORM-D NOTICE: JUDGEMENT BASED ON INDIRECT TEST DATA MATERIAL SAFETY DATA SHEET This MSDS complies with OSHA'S Hazard Communication Standard 29 CFR 1910.1200 and OSHA Form 174 Product Codes: SECTION 2 : Hazardous Ingredients/Identity Information Chemical Name CAS# PETROLEUM DISTILLATE (HYDROTREATED) 64742-47-8 OSHA PEL TWA: 5 mg/m3 (mist) ACGIH TLV TWA: 5 mg/m3 (mist) Carcinogen Paragraph:
Ref. Source **: d Chemical Name PETROLEUM OIL CAS# 64742-57-0 OSHA PEL TWA: 5 mg/m3 (mist) ACGIH TLV TWA: 5 mg/m3 (mist) Carcinogen Paragraph: Ref. Source **: d Chemical Name OXIDIZED PETROLEUM DISTILLATE CAS# 64742-18-4 OSHA PEL TWA: 5 mg/m3 (mist) ACGIH TLV TWA: 5 mg/m3 (mist) Carcinogen Paragraph: Ref. Source **: d Chemical Name CARBON DIOXIDE CAS# 124-38-9 OSHA PEL TWA: 5000 ppm ACGIH TLV TWA: 5000 ppm Carcinogen Paragraph: Ref. Source **: d Composition/Information: (Hazardous Components 1% or greater; Carcinogens 0.1% or greater) Comments: ** Chemical Listed as Carcinogen or Potential Carcinogen. [a] NTP [b] IARC Monograph [c] OSHA [d] Not Listed [e] Animal Data Only SECTION 3 : Physical And Chemical Characteristics Physical State/Appearance: Wide, conical mist of opaque, tan liquid with fine particles Color: Tan Odor: Solvent odor Vapor Pressure: PSIG @ 70 deg F (Aerosols): 70-90 (Non-Aerosols) (mm Hg and Temperature): Not Applicable Vapor Density: (Air = 1): > 1 Boiling Point: Not Applicable Solubility: In Water: Negligible Specific Gravity: (H2O = 1): Concentrate Only = 0.80 Evaporation Point: (Water = 1): < 1 FlashPoint: (Non-aerosols):
(Liquid concentrate only): > 170 deg F Auto Ignition Temp: Not Established Upper Flammable Explosive Limit: In Air by % in Volume: Not Established Lower Flammable Explosive Limit: In Air by % in Volume: Not Established Water Reactive: No SECTION 4 : Fire And Explosion Hazards Fire: FLAMMABILITY as per USA FLAME PROJECTION TEST (aerosols): Greater than 24 with flashback to tip: EXTREMELY FLAMMABLE Flash Point: (Non-aerosols): (Liquid concentrate only): > 170 deg F Upper Flammable or Explosive Limit: In Air by % in Volume: Not Established Lower Flammable or Explosive Limit: In Air by % in Volume: Not Established Auto Ignition Temperature: Not Established Extinguishing Media: Foam, dry chemical, carbon dioxide. Fire Fighting Instructions: Self-contained breathing apparatus. NFPA Health: 2 Flammability: 2 Other: Unusual Fire Hazards: Do not expose aerosols to temperatures above 130 deg F or the container may rupture. SECTION 5 : Health Hazards Applies to All Ingredients: Route of Exposure: INHALATION, INGESTION, SKIN ABSORPTION Potential Health Effects: Eye Contact: ACUTE: Irritant. Skin Contact: ACUTE: Irritant due to defatting of skin. Inhalation: ACUTE: Excessive inhalation of mists can cause nasal & respiratory irritation, dizziness, weakness, nausea, headache, possible unconsciousness or asphyxiation. Note: Vapor inhalation unlikely as solvents are not volatile. Ingestion: ACUTE: Possible chemical pneumonitis if aspirated into lungs. Chronic Health Effects: (Effects due to excessive exposure to the raw materials of this mixture) May cause cardiac abnormality, liver abnormalities, lung and kidney damage. Aggravation of Pre-Existing Conditions: May aggravate existing eye, skin, or upper respiratory conditions. SECTION 6 : Emergency And First Aid Procedures
Eye Contact: Flush with water for 15 minutes. If irritated, seek medical attention. Skin Contact: Wash with soap and water. If irritated, seek medical attention. Inhalation: Remove to fresh air. Resuscitate if necessary. Get medical attention. Ingestion: DO NOT INDUCE VOMITING. Drink two large glasses of water. Get immediate medical attention. Chemical Stability: STABLE SECTION 7 : Reactivity Data Conditions to Avoid: Open flame, welding arcs, heat, sparks. Incompatibilities with Other Materials: (Mat. to avoid): Strong oxidizing agents. Reactivity: Water Reactive: No Hazardous Polymerization: WILL NOT OCCUR Hazardous Decomposition Products: Carbon dioxide, carbon monoxide, trace oxides of sulfur and zinc in addition to unknown organic compounds. SECTION 8 : Precautions For Safe Handling Spill Cleanup Measures: Absorb with suitable medium. Incinerate or landfill according to local, state or federal regulations. DO NOT FLUSH TO SEWER. Other Precautions: KEEP OUT OF REACH OF CHILDREN. Avoid food contamination. Storage: Do not puncture or incinerate containers. Do not store at temperatures above 130 deg F. Hygiene Practices: Wash with soap and water before handling food. Waste Disposal: Aerosol cans when vented to atmospheric pressure through normal use, pose no disposal hazard. DOT Hazard Class: ORM-D SECTION 9 : Control Measures Ventilation System: Requirements: Adequate ventilation to keep vapor concentration below TLV. Hand Protection Description: Protective Gloves: Neoprene, nitrile or other solvent resistant gloves Eye/Face Protection: Safety glasses recommended. Protective Clothing/Body Protection: None Respiratory Protection: (Specify type): If vapor concentration exceeds TLV, use respirator approved by NIOSH approved for organic vapor mists.
Other Protective: None Hygienic Work Practices: Wash with soap and water before handling food. SECTION 10 : Other Information Applies to All Ingredients: OSHA 29 CFR 1200: MATERIAL SAFETY DATA SHEET This MSDS complies with OSHA'S Hazard Communication Standard 29 CFR 1910.1200 and OSHA Form 174 PETROLEUM DISTILLATE (HYDROTREATED): SARA: PETROLEUM OIL: SARA: OXIDIZED PETROLEUM DISTILLATE: SARA: CARBON DIOXIDE: SARA: HMIS: Health Hazard: 2 Fire Hazard: 2 Personal Protection: B NFPA: Fire Hazard: 2 Health: 2 MSDS Revision Date: December 10, 2007 Supersedes: 11/23/04 Revision - 2 MSDS Author: Prepared By: IB/TR Disclaimer: We believe the statements, technical information and recommendations contained herein are reliable, but they are given without warranty or guarantee of any kind. THIS MSDS IS CURRENT AS OF December 10, 2007. The DATE PREPARED section is the original date assembled and remains current until a change is necessary. This is tracked internally at the manufacturer by these date codes and therefore must remain as the originating date. Copyright 1996-2009 Actio Corporation. All Rights Reserved. ACTIO MSDS ID: 668417 View Section : 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 SECTION 1: CHEMICAL PRODUCT and COMPANY IDENTIFICATION (N/A) Product Name: Greaseless Lubricant Distributor Name: Fastenal Distributor Address: Winona, MN 55987, USA Emergency Phone: 1-813-248-0585 Distributor Telephone: 1-877-Fastenal Revision Date: August 8, 2005 Revision ##: 1 Manufacturer Name: Fastenal NFPA
Address: Winona, MN 55987, USA Emergency Phone: 1-813-248-0585 3 2 0 General Use: Business Phone: Product Use: Lubricant 1-877-Fastenal NFPA 704: National Fire Protection Association Hazard Rating: 0 = Minimal 1 = Slight 2 = Moderate 3 = Severe 4 = Extreme Product Codes: 0605050 SECTION 2 : COMPOSITION, INFORMATION ON INGREDIENTS Ingredient Name CAS# Ingredient Percent Distillates (petroleum), hydrotreated light 64742-47-8 60-100% by Weight EC Index Number: 1 Distillates (petroleum), solvent-refined heavy paraffinic 64741-88-4 5-10% by Weight EC Index Number: 1 Carbon dioxide 124-38-9 1-5% by Weight EC Index Number: 1 SECTION 3 : HAZARDS IDENTIFICATION Emergency Overview: DANGER EXTREMELY FLAMMABLE AEROSOL. CONTENTS UNDER PRESSURE. CONTAINER MAY EXPLODE IF HEATED. HARMFUL OR FATAL IF SWALLOWED. CANCER HAZARD. CONTAINS MATERIAL WHICH MAY CAUSE CANCER.* MAY CAUSE EYE IRRITATION. MAY CAUSE SKIN IRRITATION. Do not puncture. Do not burn. Store away from heat. * According to Canadian WHMIS. See Section 15 for California, USA information. Applies to All Ingredients : Route of Exposure: Potential Health Effects: Eye Contact: Skin Contact: Inhalation: Ingestion: Chronic Health Effects: Target Organs: Signs/Symptoms: Aggravation of Pre-Existing Conditions: Skin contact, skin absorption, eye contact, and inhalation. See Section 11 for more information. May irritate eyes. May irritate skin. Excessive intentional inhalation may cause respiratory tract irritation and central nervous system effects (headache, dizziness). Aspiration of material into lungs can cause chemical pneumonitis. May cause stomach distress, nausea or vomiting. Prolonged or repeated exposure can cause drying, defatting and dermatitis. Symptoms may include discomfort or pain, excess blinking and tear production, with marked redness and swelling of the conjunctiva. Symptoms may include redness, edema, drying, defatting and cracking of the skin. Certain pre-existing conditions may make workers particularly susceptible to the effects of this chemical: asthma, allergies, impaired pulmonary function. This product is a "Hazardous Chemical" as defined by the OSHA Hazard Communication Standard, 29 CFR 1910.1200. Potential Environmental Effects: See Section 12 for more information. This product is not expected to produce significant ecotoxicity upon exposure to aquatic organisms and aquatic systems. SECTION 4 : FIRST AID MEASURES Eye Contact: Skin Contact: Flush with cool water. Remove contact lenses, if applicable, and continue flushing. Obtain medical attention if irritation persists. After contact with skin, wash immediately with plenty of water. Remove and wash contaminated clothing before re-use. If irritation persists, get
Inhalation: Ingestion: Note to Physicians: medical attention. If breathed in, move person into fresh air. If symptoms persist, obtain medical attention. If breathing has stopped, trained personnel should administer CPR immediately. If swallowed, call a Poison Control Centre or doctor immediately. DO NOT induce vomiting. Never give anything by mouth if victim is unconscious, or is convulsing. If swallowed, rinse mouth with water (only if the person is conscious). Symptoms may be delayed. General Advice: In case of accident or if you feel unwell, seek medical advice immediately (show the label or MSDS where possible). SECTION 5 : FIRE FIGHTING MEASURES Fire: Flash Point: Upper Flammable or Explosive Limit: Lower Flammable or Explosive Limit: Auto Ignition Temperature: Extinguishing Media: Unsuitable Media: Hazardous Combustion Byproducts: Fire Fighting Instructions: Sensitivity to Impact: Static Discharge Effects: NFPA Flammability: FLAMMABILITY as per USA FLAME PROJECTION TEST (aerosols): EXTREMELY FLAMMABLE. Flammable aerosol by WHMIS criteria. (Of concentrate): Powder, water spray, foam, carbon dioxide. Oxides of carbon. Oxides of carbon. Oxides of sulfur. Oxides of zinc. Protection of Firefighters: Pressurized container may explode when exposed to heat or flame. In case of fire and/or explosion do not breathe fumes. Firefighters should wear full protective clothing including self contained breathing apparatus. Sensitivity to Mechanical Impact: Health: 2 Flammability:3 Other: SECTION 6 : ACCIDENTAL RELEASE MEASURES Personal Precautions: Spill Cleanup Measures: Environmental Precautions: Other Information: Use personal protection recommended in Section 8. Isolate area. Remove sources of ignition. Keep unnecessary personnel away. Ruptured cylinders may rocket. Sweep up or gather material and place in appropriate container for disposal. Allow gas to dissipate into the atmosphere. Methods for Containment: Prevent further leakage or spillage if safe to do so. Use sand, perlite or vermiculite as an absorbent for large spills of this material. Many gases are heavier than air and will spread along ground and collect in low or confined areas (sewers, basements, tanks). SECTION 7 : HANDLING and STORAGE Handling: Keep away from heat, open flames or other sources of ignition. Avoid contact with eyes. Avoid contact with skin. Do not swallow. Do not breathe gas/fumes/vapor/spray. Use only in a well-ventilated area. When using do not eat or drink. Wash hands before breaks and immediately after handling the product. Storage: Keep out of the reach of children. Do not store at temperatures above 49 deg C. Store in a cool, dry, well-ventilated area. Keep away from food, drink and animal feedingstuffs. Hygiene Practices: Handle in accordance with good industrial hygiene and safety practice. SECTION 8 : EXPOSURE CONTROLS, PERSONAL PROTECTION Engineering Controls: Skin Protection Description: Hand Protection Description: Eye/Face Protection: Protective Clothing/Body Protection: Respiratory Protection: Provide adequate local exhaust ventilation to maintain worker exposure below exposure limits. Wear suitable protective clothing. Wear suitable gloves. Wear safety glasses with side shields. Wear suitable protective clothing. In case of insufficient ventilation, wear suitable respiratory equipment. General Hygiene Considerations: Handle in accordance with good industrial hygiene and safety practice. Ingredient Guidelines Ingredient: Carbon dioxide
Guideline Type: OSHA PEL-TWA Guideline Information: 5000 ppm Guideline Type: ACGIH TLV-TWA Guideline Information: 5000 ppm Ingredient: Distillates (petroleum), hydrotreated light Guideline Type: OSHA PEL-TWA Guideline Information: 100 ppm Guideline Type: ACGIH TLV-TWA Guideline Information: Not available Ingredient: Distillates (petroleum), solvent-refined heavy paraffinic Guideline Type: OSHA PEL-TWA Guideline Information: 5 mg/m3 (mist) Guideline Type: ACGIH TLV-TWA Guideline Information: 5 mg/m3 (mist) SECTION 9 : PHYSICAL and CHEMICAL PROPERTIES Physical State/Appearance: Opaque. Color: Tan. Odor: Solvent. Physical State: Gas/Pressurized Liquid. ph: (Of concentrate): Vapor Pressure: (Of concentrate): Vapor Density: (Of concentrate): Boiling Point: (Of concentrate): Freezing Point: (Of concentrate): Solubility: In Water (of concentrate): Negligible. Specific Gravity: (Of concentrate): 0.80 Evaporation Point: (Of concentrate): Percent Volatile: Wt. %: 99.79 Volatile Organic Compound Wt. %: 0 Content: Viscosity: (Of concentrate): Water thin. Odor Threshold: Coefficient of Water/Oil Distribution: SECTION 10 : STABILITY and REACTIVITY Chemical Stability: Incompatibilities with Other Materials: Reactivity: Hazardous Decomposition Products: Stable under recommended storage conditions. Contents under pressure. Container may explode if heated. Do not puncture. Do not burn. Oxidizers. Conditions of Reactivity: No dangerous reaction known under conditions of normal use. Possibility of Hazardous Reactions: Will not occur. Oxides of carbon. Oxides of carbon. Oxides of sulfur. Oxides of zinc. SECTION 11 : TOXICOLOGICAL INFORMATION Applies to all ingredients: Eye Effect: Skin Effects: Ingestion Effects: Inhalation Effects: Chronic Effects: Carcinogenicity: Mutagenicity: Teratogenicity: Embryo Toxicity: Sensitization: May irritate eyes. Symptoms may include discomfort or pain, excess blinking and tear production, with marked redness and swelling of the conjunctiva. May irritate skin. Symptoms may include redness, edema, drying, defatting and cracking of the skin. Not a normal route of exposure. May cause stomach distress, nausea or vomiting. Excessive intentional inhalation may cause respiratory tract irritation and central nervous system effects (headache, dizziness). Aspiration of material into lungs can cause chemical pneumonitis. Not hazardous by WHMIS/OSHA criteria. Hazardous by WHMIS criteria. Not hazardous by WHMIS/OSHA criteria. Not hazardous by WHMIS/OSHA criteria. Not hazardous by WHMIS/OSHA criteria. Respiratory Sensitization: Not hazardous by WHMIS/OSHA criteria. Skin Sensitization: Not hazardous by WHMIS/OSHA criteria. Reproductive Toxicity: Not hazardous by WHMIS/OSHA criteria. Other Toxicological Target Organs: Information: Toxicologically Synergistic Materials: Distillates (petroleum), hydrotreated light : Ingestion Effects: LD50 (oral): > 5000 mg/kg, rat Inhalation Effects: LC50: Not available Carcinogenicity: Chemical Listed as Carcinogen or Potential Carcinogen: NTP: No IARC: No OSHA: No ACGIH: No Distillates (petroleum), solvent-refined heavy paraffinic : Ingestion Effects: LD50 (oral): > 5000 mg/kg, rat
Inhalation Effects: Carcinogenicity: Carbon dioxide : Ingestion Effects: Inhalation Effects: Carcinogenicity: LC50: > 5000 mg/m3 4 hrs, rat Chemical Listed as Carcinogen or Potential Carcinogen: NTP: No IARC: No OSHA: No ACGIH: No LD50 (oral): Not available LC50: Not available Chemical Listed as Carcinogen or Potential Carcinogen: NTP: No IARC: No OSHA: No ACGIH: No SECTION 12 : ECOLOGICAL INFORMATION Ecotoxicity: Bioaccumulation: Persistence/Degradability: This product is not expected to produce significant ecotoxicity upon exposure to aquatic organisms and aquatic systems. Accumulation: Mobility in Environment: SECTION 13 : DISPOSAL CONSIDERATIONS Waste Disposal: This material and its container must be disposed of in a safe way. Dispose in accordance with all applicable regulations. SECTION 14 : TRANSPORT INFORMATION DOT Hazard Class: ORM-D IATA Shipping Name: AEROSOLS, flammable IATA UN Number: UN1950 IATA Class: 2.1 Canadian TDG: Limited Quantity SECTION 15 : REGULATORY INFORMATION Applies to all ingredients: TSCA 8(b): Inventory Status: OSHA 29 CFR 1200: Ingredients on List: Yes MSDS prepared pursuant to the Hazard Communication Standard (CFR29 1910.1200). State: California Safe Drinking Water and Toxic Enforcement Act of 1986 (Proposition 65): This product does not contain a chemical known to the State of California to cause cancer, birth defects or other reproductive harm. Canada WHMIS: Canada DSL: Canada NDSL: WHMIS Classification: Class A - Compressed Gas Class B5 - Flammable Aerosol Class D2A - Carcinogenicity This product has been classified in accordance with the hazard criteria of the Controlled Products Regulations and the MSDS contains all the information required by the Controlled Products Regulations. Ingredients on List: Yes Ingredients on List: No NFPA 704: National Fire Protection Association Health - 2 Fire - 3 Reactivity - 0 Hazard Rating: 0 = Minimal 1 = Slight 2 = Moderate 3 = Severe 4 = Extreme SECTION 16 : ADDITIONAL INFORMATION NFPA: Health: 2 Fire Hazard: 3 MSDS Revision Date: August 8, 2005 Revision ##: 1
MSDS Author: Prepared by: Nexreg Compliance Inc. Phone: (519) 488-5126 Web: www.nexreg.ca Disclaimer: The information contained in this document applies to this specific material as supplied. It may not be valid for this material if it is used in combination with any other materials. It is the user s responsibility to satisfy oneself as to the suitability and completeness of this information for the user s own particular use. NFPA 704: National Fire Protection Association Hazard Rating: 0 = Minimal 1 = Slight 2 = Moderate 3 = Severe 4 = Extreme Expiry Date: August 8, 2008 Formula ##: A00384 Copyright 1996-2009 Actio Corporation. All Rights Reserved.