MATERIAL SAFETY DATA SHEET 1. Product and Company Identification Material name Revision date 11-25-2014 Version # 01 CAS # Mixture Product code 46361, 46388, 46392, 56362, 34016, 34032, 34128, MICHAELS SKUs:558155 MSDS Number 7806910 Product use Casting Resin Catalyst Agent Manufacturer/Supplier Environmental Technology, Inc. 300 S. Bay Depot Road Fields Landing CA 95537 eti@eti-usa.com Telephone number 707-443-9323 Contact Person: Technical Director Emergency CHEMTREC 800-424-9300 2. Hazards Identification Physical state Appearance Emergency overview OSHA regulatory status Potential health effects Routes of exposure Eyes Skin Inhalation Ingestion Target organs Signs and symptoms Potential environmental effects Liquid. Water white liquid. DANGER Contains an organic peroxide and strong oxidizer. Contact with other materials may cause fire. Heat may cause containers to explode. Causes severe skin and eye irritation. May cause respiratory tract irritation. This product is considered hazardous under 29 CFR 1910.1200 (Hazard Communication). Inhalation. Ingestion. Skin contact. Eye contact. Causes severe eye irritation. Permanent eye damage or blindness could result. Causes severe skin irritation. May cause redness and pain. May cause respiratory tract irritation. May cause nausea, vomiting and gastrointestinal burns. Eyes. Skin. Gastrointestinal tract. Respiratory system. Contact with this material will cause burns to the skin, eyes and mucous membranes. The product is not classified as environmentally hazardous. However, this does not exclude the possibility that large or frequent spills can have a harmful or damaging effect on the environment. 3. Composition / Information on Ingredients CAS # Percent Peroxide Composition comments 131-11-3 < 50 1338-23-4 < 40 All concentrations are in percent by weight unless ingredient is a gas. Gas concentrations are in percent by volume. 4. First Aid Measures First aid procedures Eye contact Skin contact Inhalation Immediately flush eyes with plenty of water for at least 15 minutes, lifting upper and lower eyelids occasionally. Continue rinsing. Get medical attention immediately. Remove and isolate contaminated clothing and shoes. Immediately flush with plenty of water for at least 15 minutes. Get medical attention immediately. Move to fresh air. Get medical attention if any discomfort continues. 1 / 7
Ingestion tes to physician General advice 5. Fire Fighting Measures Flammable properties Extinguishing media Suitable extinguishing media Unsuitable extinguishing media Protection of firefighters Protective equipment and precautions for firefighters Fire fighting equipment/instructions Hazardous combustion products Rinse mouth thoroughly with water and give large amounts of water to people not unconscious. Never give anything by mouth to a victim who is unconscious or is having convulsions. Do NOT induce vomiting. If vomiting occurs naturally, have victim lean forward to reduce risk of aspiration. Treat symptomatically. Ensure that medical personnel are aware of the material(s) involved, and take precautions to protect themselves. The product is not flammable. Contains an organic peroxide. Strong oxidizer - contact with other material may cause fire. Heat may cause the containers to explode. Use extinguishing agent suitable for type of surrounding fire. Water. Do not use water jet as an extinguisher, as this will spread the fire. Self-contained breathing apparatus and full protective clothing must be worn in case of fire. Move container from fire area if it can be done without risk. The heat of decomposition of the peroxides adds to the heat of the fire. Dry chemical fire extinguishing agent may catalyze the decomposition. 6. Accidental Release Measures Personal precautions Environmental precautions Methods for cleaning up Avoid contact with skin and eyes. Wear protective clothing as described in Section 8 of this safety data sheet. Avoid discharge into storm drains, water courses or onto the ground. Runoff from fire control or dilution water may be corrosive and/or toxic and cause pollution. Should not be released into the environment. Large Spills: Stop the flow of material, if this is without risk. Dike the spilled material, where this is possible. Cover with plastic sheet to prevent spreading. Prevent product from entering drains. Do not allow material to contaminate ground water system. Use a non-combustible material like vermiculite, sand or earth to soak up the product and place into a container for later disposal. Following product recovery, flush area with water. Small Spills: Wipe up with absorbent material (e.g. cloth, fleece). Clean surface thoroughly to remove residual contamination. Other information 7. Handling and Storage Handling Storage Never return spills in original containers for re-use. Clean up in accordance with all applicable regulations. This material and its container must be disposed of as hazardous waste. Clean up in accordance with all applicable regulations. Use a non-combustible material like vermiculite, sand or earth to soak up the product and place into a container for later disposal. Provide adequate ventilation. Avoid contact with eyes, skin, and clothing. Keep away from all ignition sources including heat, sparks and flame. When using spray equipment, never spray raw MEKP into curing or in to raw resin of flues. Good personal hygiene is necessary. Wash hands and contaminated areas with water and soap before leaving the work site. Observe good industrial hygiene practices. Store in tightly closed original container in a dry, cool and well-ventilated place. Protect from direct sunlight. Store away from incompatible materials. 8. Exposure Controls / Personal Protection Occupational exposure limits US. ACGIH Threshold Limit s 2 / 7
US. OSHA Table Z-1 Limits for Air Contaminants (29 CFR 1910.1000) PEL Canada. Alberta OELs (Occupational Health & Safety Code, Schedule 1, Table 2) 1.4 mg/m3 Canada. British Columbia OELs. (Occupational Exposure Limits for Chemical Substances, Occupational Health and Safety Regulation 296/97, as amended) Canada. Ontario OELs. (Ministry of Labor - Control of Exposure to Biological or Chemical Agents) 1. Canada. Quebec OELS. (Ministry of Labor - Regulation Respecting the Quality of the Work Environment) 1. Mexico. Occupational Exposure Limit s STEL 10 mg/m3 1. Exposure guidelines Use personal protective equipment as required. Keep working clothes separately. Engineering controls Provide adequate ventilation and minimize the risk of inhalation of vapors. Personal protective equipment Eye / face protection Wear splash-proof eye goggles to prevent any possibility of eye contact. Skin protection Wear protective gloves. The most suitable glove must be chosen in consultation with the gloves supplier, who can inform about the breakthrough time of the glove material. Wear appropriate chemical resistant clothing to prevent any possibility of skin contact. Respiratory protection A NIOSH- approved air purifying respirator with an organic vapor cartridge or canister may be permissible under certain circumstances where airborne concentrations are expected to exceed exposure limits. General hygiene considerations 9. Physical & Chemical Properties Appearance Color Odor Odor threshold Physical state Wash at the end of each work shift and before eating, smoking and using the toilet. When using, do not eat, drink or smoke. Water white liquid. White. Slight. Liquid. 3 / 7
Form ph Melting point Freezing point Boiling point Flash point Evaporation rate Flammability limits in air, upper, % by volume Flammability limits in air, lower, % by volume Vapor pressure Vapor density > 1 Specific gravity 1.1 Solubility (water) Partition coefficient (n-octanol/water) Auto-ignition temperature Decomposition temperature Liquid. > 200 F (> 93.3 C) Slightly solble in water. 10. Chemical Stability & Reactivity Information Chemical stability Conditions to avoid Incompatible materials Hazardous decomposition products Possibility of hazardous reactions 11. Toxicological Information Stable under normal temperature conditions and recommended use. Heat, sparks, flames, elevated temperatures. Protect against direct sunlight. Strong oxidizers, strong acids, and strong bases. Reducing agents. Sulfur compounds. Metal salts. When heated to decomposition the product emits acrid smoke and irritating fumes. Hazardous polymerization does not occur. Toxicological data Test Results Acute effects Local effects Sensitization Chronic effects Carcinogenicity Epidemiology Mutagenicity Reproductive effects Symptoms and target organs May cause discomfort if swallowed. Acute Dermal LD50 Rat: 38000 mg/kg Acute Oral LD50 Rat: 2400 mg/kg Acute Inhalation LC50 Rat: 200 mg/l 4 Hours Acute Oral LD50 Rat: 6.86 ml/kg Causes severe skin and eye irritation. Vapors and mist may irritate throat and respiratory system and cause coughing. data available. Prolonged exposure may cause chronic effects. This product is not considered to be a carcinogen by IARC, ACGIH, NTP, or OSHA. epidemiological data is available for this product. data available. data available. Contact with this material will cause burns to the skin, eyes and mucous membranes. 4 / 7
12. Ecological Information Ecotoxicological data Ecotoxicity Environmental effects Persistence and degradability Bioaccumulation / Accumulation Partition coefficient (n-octanol/water) Mobility in environmental media Test Results EC50 Water flea (Daphnia magna): 45.9 mg/l 48 hours LC50 Sheepshead minnow (Cyprinodon variegatus): 29 mg/l 96 hours The product is not classified as environmentally hazardous. However, this does not exclude the possibility that large or frequent spills can have a harmful or damaging effect on the environment. An environmental hazard cannot be excluded in the event of unprofessional handling or disposal. data is available on the degradability of this product. data available on bioaccumulation. This substance has very low solubility in water and low mobility in the environment. 13. Disposal Considerations Waste codes Disposal instructions Waste from residues / unused products Contaminated packaging 14. Transport Information U160: Waste Methyl ethyl ketone peroxide Dispose of waste material according to Local, State, Federal, and Provincial Environmental Regulations. Do not allow this material to drain into sewers/water supplies. Dispose of in accordance with local regulations. Since emptied containers may retain product residue, follow label warnings even after container is emptied. DOT UN3105 Proper shipping name Organic peroxide type D, liquid ( Peroxide <40%) Packing group II Environmental hazards Labels required Additional information: Packaging exceptions 152 Packaging non bulk 225 Packaging bulk ne IATA 3105 Proper shipping name Organic peroxide type D, liquid ( Peroxide <40%) Environmental hazards Additional information: ERG code 5L IMDG 3105 Proper shipping name ORGANIC PEROXIDE TYPE D, LIQUID ( Peroxide <40%) 5 / 7
Environmental hazards EmS. TDG Proper shipping name Packing group Additional information: Special provisions 15. Regulatory Information F-J, S-R ORGANIC PEROXIDE TYPE D, LIQUID ( Peroxide <40%) UN3105 II 16, 38 US federal regulations This product is a "Hazardous Chemical" as defined by the OSHA Hazard Communication Standard, 29 CFR 1910.1200. All components are on the U.S. EPA TSCA Inventory List. TSCA Section 12(b) Export tification(40 CFR 707, Subpt. D) t regulated. US CAA Section 112 Hazardous Air Pollutants (HAPs) List DIMETHYL PHTHALATE (CAS 131-11-3) US EPCRA (SARA Title III) Section 313 - Toxic Chemical: De minimis concentration (CAS 131-11-3) 1.0 % US EPCRA (SARA Title III) Section 313 - Toxic Chemical: Listed substance (CAS 131-11-3) CERCLA (Superfund) reportable quantity (lbs) (40 CFR 302.4) : 5000 Meth yl Ethyl Ketone Peroxide: 10 Superfund Amendments and Reauthorization Act of 1986 (SARA) Hazard categories Immediate Hazard - Delayed Hazard - Fire Hazard - Pressure Hazard - Reactivity Hazard - Section 302 extremely hazardous substance (40 CRF 355, Appendix A) Section 311/312 (40 CFR 370) Drug Enforcement t controlled Administration (DEA) (21 CFR 1308.11-15) Canadian regulations This product has been classified in accordance with the hazard criteria of the CPR and the MSDS contains all the information required by the CPR. WHMIS status Controlled WHMIS classification D2B - Other Toxic Effects-TOXIC WHMIS labeling Inventory status Country(s) or region Inventory name On inventory (yes/no)* Australia Australian Inventory of Chemical Substances (AICS) Canada Domestic Substances List (DSL) Canada n-domestic Substances List (NDSL) China Inventory of Existing Chemical Substances in China (IECSC) 6 / 7
Country(s) or region Inventory name On inventory (yes/no)* Europe European Inventory of Existing Commercial Chemical Substances (EINECS) Europe Japan Korea New Zealand Philippines United States & Puerto Rico European List of tified Chemical Substances (ELINCS) Inventory of Existing and New Chemical Substances (ENCS) Existing Chemicals List (ECL) New Zealand Inventory Philippine Inventory of Chemicals and Chemical Substances (PICCS) Toxic Substances Control Act (TSCA) Inventory *A "" indicates that all components of this product comply with the inventory requirements administered by the governing country(s) State regulations This product does not contain a chemical known to the State of California to cause cancer, birth defects or other reproductive harm. US - California Hazardous Substances (Director's): Listed substance (CAS 131-11-3) Peroxide (CAS 1338-23-4) US - Massachusetts RTK - Substance: Listed substance (CAS 131-11-3) Peroxide (CAS 1338-23-4) US - New Jersey Community RTK (EHS Survey): Reportable threshold (CAS 131-11-3) 500 LBS US - New Jersey RTK - Substances: Listed substance (CAS 131-11-3) Peroxide (CAS 1338-23-4) US - Pennsylvania RTK - Hazardous Substances: Listed substance (CAS 131-11-3) Peroxide (CAS 1338-23-4) Mexico regulations This safety data sheet was prepared in accordance with the Official Mexican Standard (NOM-018-STPS-2000). 16. Other Information Further information HMIS is a registered trade and service mark of the NPCA. HMIS ratings Health: 3* Flammability: 2 Physical hazard: 2 NFPA ratings Health: 3 Flammability: 2 Instability: 2 Disclaimer The information in the sheet was written based on the best knowledge and experience currently available. Issue date 08-22-2011 7 / 7