SAFETY DATA SHEET According to Regulation (EC) No 1907/2006 1 IDENTIFICATION OF THE SUBSTAE/PREPARATION AND OF THE COMPANY/UNDERTAKING PRODUCT NAME PRODUCT NO. 65893 APPLICATION SUPPLIER Leather Treatment Cyclo Industries Inc. Regent House Business Centre 24-25 Nutford Place Marble Arch London W1H 5YN 0797 6921836 E mail ehs@cyclo.com EMERGEY TELEPHONE 001 312 906 6194 2 HAZARDS IDENTIFICATION Not regarded as a health or environmental hazard under current legislation. CLASSIFICATION (1999/45) HUMAN HEALTH See section 11 for additional information on health hazards. 3 COMPOSITION/INFORMATION ON INGREDIENTS Name EC No. CAS-No. Content % Classification (67/548/EEC) ACRYLIC ACID HOMOPOLYMER 9003-01-4 1-5% - ALKYL POLYETHOXY ETHANOL 60828-78-6 1-5% Xi;R41. DIETHANOLAMINE 203-868-0 111-42-2 < 1% Xn;R22,R48/22 Xi;R38,R41 ETHANEDIOL 203-473-3 107-21-1 5-15% Xn;R22 FORMALDEHYDE...% 200-001-8 50-00-0 <0.002% Carc. Cat. 3;R40 T;R23/24/25 C;R34 R43 GLYCEROL 200-289-5 56-81-5 5-10% - LANOLIN ETHOXYLATED 61790-81-6 5-15% - POLYDIMETHYLSILOXANE 63148-62-9 5-15% - TRIETHANOLAMINE 99% 203-049-8 102-71-6 1-5% Xi;R36/38. The Full Text for all R-Phrases is Displayed in Section 16 4 FIRST-AID MEASURES INHALATION Remove victim immediately from source of exposure. Provide fresh air, warmth and rest, preferably in a comfortable upright sitting position. Get medical attention if any discomfort continues. 1 / 5
INGESTION NEVER MAKE AN UONSCIOUS PERSON VOMIT OR DRINK FLUIDS! Do not induce vomiting. If vomiting occurs, the head should be kept low so that stomach vomit doesn't enter the lungs. Rinse mouth thoroughly. Provide rest, warmth and fresh air. Get medical attention. SKIN CONTACT Remove contaminated clothing immediately and wash skin with soap and water. Continue to rinse for at least 15 minutes. Get medical attention if irritation persists after washing. EYE CONTACT Make sure to remove any contact lenses from the eyes before rinsing. Promptly wash eyes with plenty of water while lifting the eye lids. Continue to rinse for at least 15 minutes. Get medical attention if any discomfort continues. 5 FIRE-FIGHTING MEASURES EXTINGUISHING MEDIA Extinguish with alcohol-resistant foam, carbon dioxide or dry powder. Do not use water jet as an extinguisher, as this will spread the fire. SPECIAL FIRE FIGHTING PROCEDURES Move container from fire area if it can be done without risk. Cool containers exposed to flames with water until well after the fire is out. UNUSUAL FIRE & EXPLOSION HAZARDS No unusual fire or explosion hazards noted. SPECIFIC HAZARDS Fire creates: Toxic gases/vapours/fumes of: Carbon monoxide (CO). Carbon dioxide (CO2). Nitrous gases (NOx). PROTECTIVE MEASURES IN FIRE Self contained breathing apparatus and full protective clothing must be worn in case of fire. 6 ACCIDENTAL RELEASE MEASURES PERSONAL PRECAUTIONS Wear protective clothing as described in Section 8 of this safety data sheet. ENVIRONMENTAL PRECAUTIONS The product should not be dumped in nature but collected and delivered according to agreement with the local authorities. SPILL CLEAN UP METHODS Stop leak if possible without risk. DO NOT touch spilled material! Absorb in vermiculite, dry sand or earth and place into containers. Collect spillage in containers, seal securely and deliver for disposal according to local regulations. 7 HANDLING AND STORAGE USAGE PRECAUTIONS Avoid inhalation of vapours/spray and contact with skin and eyes. Observe good chemical hygiene practices. STORAGE PRECAUTIONS Store in tightly closed original container in a dry, cool and well-ventilated place. Keep away from heat, sparks and open flame. 8 EXPOSURE CONTROLS/PERSONAL PROTECTION Name STD TWA - 8 Hrs STEL - 15 Min Notes ETHANEDIOL WEL 10 mg/m3 104 mg/m3 Sk GLYCEROL WEL 10 mg/m3 WEL = Workplace Exposure Limit. Sk = Can be absorbed through skin. PROTECTIVE EQUIPMENT 2 / 5
ENGINEERING MEASURES Provide adequate general and local exhaust ventilation. RESPIRATORY EQUIPMENT No specific recommendation made, but respiratory protection may still be required under exceptional circumstances when excessive air contamination exists. Chemical respirator with organic vapour cartridge. HAND PROTECTION Wear protective gloves. Use protective gloves made of: Viton rubber (fluor rubber). or Polyvinyl alcohol (PVA). EYE PROTECTION Wear approved safety goggles. Use face shield in case of splash risk. OTHER PROTECTION Provide eyewash station. HYGIENE MEASURES No specific hygiene procedures noted, but good personal hygiene practices are always advisable, especially when working with chemicals. When using do not eat, drink or smoke. SKIN PROTECTION Wear apron or protective clothing in case of contact. 9 PHYSICAL AND CHEMICAL PROPERTIES APPEARAE COLOUR ODOUR SOLUBILITY Coloured paste Tan Characteristic Completely soluble in water BOILING POINT ( C) 103.9 C RELATIVE DENSITY 0.90 VAPOUR DENSITY (air=1) 2.1 EVAPORATION RATE 1.35 (EtEt=1) VOLATILE BY VOL. (%) 90 ph-value, CO. SOLUTION 6 FLASH POINT ( C) 110 C PM Closed cup. 10 STABILITY AND REACTIVITY STABILITY Stable under normal temperature conditions and recommended use. CONDITIONS TO AVOID Avoid excessive heat for prolonged periods of time. Avoid contact with strong oxidisers. MATERIALS TO AVOID Strong oxidising substances. HAZARDOUS DECOMPOSITION PRODUCTS In case of fire, toxic gases (CO, CO2, NOx) may be formed. 11 TOXICOLOGICAL INFORMATION GENERAL INFORMATION This product has low toxicity. Only large volumes may have adverse impact on human health. INHALATION In high concentrations, vapours may irritate throat and respiratory system and cause coughing. INGESTION May cause discomfort if swallowed. May cause stomach pain or vomiting. 3 / 5
SKIN CONTACT Prolonged contact may cause redness and irritation. EYE CONTACT May cause temporary eye irritation. 12 ECOLOGICAL INFORMATION ECOTOXICITY The product components are not classified as environmentally hazardous. However, this does not exclude the possibility that large or frequent spills can have a harmful or damaging effect on the environment. MOBILITY The product is soluble in water. 13 DISPOSAL CONSIDERATIONS GENERAL INFORMATION When handling waste, consideration should be made to the safety precautions applying to handling of the product. DISPOSAL METHODS Dispose of waste and residues in accordance with local authority requirements. 14 TRANSPORT INFORMATION GENERAL ROAD TRANSPORT NOTES RAIL TRANSPORT NOTES SEA TRANSPORT NOTES AIR TRANSPORT NOTES The product is not covered by international regulation on the transport of dangerous goods (IMDG, IATA, ADR/RID). 15 REGULATORY INFORMATION RISK PHRASES SAFETY PHRASES EU DIRECTIVES Regulation (EC) No 1907/2006 of the European Parliament and of the Council of 18 December 2006 concerning the Registration, Evaluation, Authorisation and Restriction of Chemicals (REACH), establishing a European Chemicals Agency, amending Directive 1999/45/EC and repealing Council Regulation (EEC) No 793/93 and Commission Regulation (EC) No 1488/94 as well as Council Directive 76/769/EEC and Commission Directives 91/155/EEC, 93/67/EEC, 93/105/EC and 2000/21/EC, including amendments. GUIDAE NOTES Workplace Exposure Limits EH40. 16 OTHER INFORMATION REVISION DATE October 2010 REV. NO./REPL. SDS GENERATED 2 DATE October 2010 4 / 5
RISK PHRASES IN FULL R34 Causes burns. R22 Harmful if swallowed. R48/22 Harmful: danger of serious damage to health by prolonged exposure if swallowed. R36/38 Irritating to eyes and skin. R37 Irritating to respiratory system. R38 Irritating to skin. R40 Limited evidence of a carcinogenic effect. R43 May cause sensitisation by skin contact. R41 Risk of serious damage to eyes. R23/24/25 Toxic by inhalation, in contact with skin and if swallowed. DISCLAIMER Cyclo Industries Inc provides the information contained herein in good faith but makes no representation as to its comprehensiveness or accuracy. Individuals receiving this information must exercise their independent judgment in determining its appropriateness for a particular purpose. Cyclo Industries Inc. makes no representations or warranties either expressed or implied, of merchantability, fitness for a particular purpose with respect to the information set forth herein or to the product to which the information refers. Accordingly, Cyclo Industries Inc. will not be reponsible for damages resulting from use of or reliance upon this information. 5 / 5