Page: 1 Product Code: Product Name: Company Name: Web site address: 1. Product and Company Identification 213 SUNBELT LABORATORIES P.O. BOX 1563 STAFFORD, TX 77497 www.sunbelt-labs.com Phone Number: (281)261-4747 Emergency Contact: CHEM-TEL (8)255-3924 Skin Corrosion/Irritation, Category 2 Serious Eye Damage/Eye Irritation, Category 2B Skin Sensitization, Category 1B 2. Hazards Identification GHS Signal Word: GHS Hazard Phrases: GHS Precaution Phrases: GHS Response Phrases: GHS Storage and Disposal Phrases: OSHA Regulatory Status: Potential Health Effects (Acute and Chronic): Inhalation: Skin Contact: Eye Contact: Ingestion: Warning Causes skin irritation. May cause an allergic skin reaction. Causes eye irritation. Wash hands thoroughly after handling. IF ON SKIN: Wash with plenty of soap and water. IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. Specific treatment see... on this label. If skin irritation occurs, get medical advice/attention. If skin irritation or rash occurs, seek medical advice/attention. If eye irritation persists, get medical advice/attention. Take off contaminated clothing and wash it before reuse. Dispose of contents/container to... This material is classified as hazardous under OSHA regulations. None. May be harmful if absorbed through the skin. Causes severe eye irritation. Harmful if swallowed. 3. Composition/Information on Ingredients CAS # Hazardous Components (Chemical Name) Concentration 131-73-2 Sodium hydroxide.2-2. % 27177-77-1 Benzenesulfonic acid, dodecyl-, potassium salt 5. -1. % 67-63- Isopropyl alcohol.2-2. % 6863-42-9 Cocamide DEA <=.99 % 12-71-6 Triethanolamine 1. -5. %
Page: 2 4. First Aid Measures Emergency and First Aid Procedures: In Case of Skin Contact: In Case of Eye Contact: In Case of Ingestion: Signs and Symptoms Of Exposure: Note to Physician: Rinse skin with water/shower. Rinse thoroughly with plenty of water for at least 15 minutes and consult a physician. In case of contact, immediately flush eyes with copious amounts of water for at least 15 minutes. Do NOT induce vomiting. Never give anything by mouth to an unconscious person. Rinse mouth with water. Consult a physician. If swallowed, wash out mouth with water provided person is conscious. Gastrointestinal disturbances. Nausea, vomiting, diarrhea. Dermatitis. To the best of our knowledge, the chemical, physical, and toxicological properties have not been thoroughly investigated. Consult a physician. Show this safety data sheet to the doctor in attendance. Move out of dangerous area. 5. Fire Fighting Measures Flash Pt: Explosive Limits: LEL: UEL: Autoignition Pt: Fire Fighting Instructions: Suitable Extinguishing Media: Use extinguishing measures that are appropriate to local circumstances and the surrounding environment. Suitable: Water spray. Wear self contained breathing apparatus for fire fighting if necessary. Further information: The product itself does not burn. Protective Equipment: Wear self-contained breathing apparatus and protective clothing to prevent contact with skin and eyes. Specific Hazard(s): Flammable Properties and Hazards: 6. Accidental Release Measures Steps To Be Taken In Case Material Is Released Or Spilled: Personal precautions. Use personal protective equipment. 7. Handling and Storage Precautions To Be Taken in Handling: Precautions To Be Taken in Storing: Avoid contact with eyes, skin, and clothing. Keep container tightly closed in a dry and well-ventilated place. 8. Exposure Controls/Personal Protection
Page: 3 CAS # Partial Chemical Name OSHA TWA ACGIH TWA Other Limits 131-73-2 Sodium hydroxide PEL: 2 mg/m3 CEIL: 2 mg/m3 27177-77-1 Benzenesulfonic acid, dodecyl-, potassium salt 67-63- Isopropyl alcohol PEL: 4 ppm TLV: 2 ppm STEL: 4 ppm 6863-42-9 Cocamide DEA 12-71-6 Triethanolamine Respiratory Equipment (Specify Type): Eye Protection: Protective Gloves: Other Protective Clothing: Engineering Controls (Ventilation etc.): Work/Hygienic/Maintenance Practices: Respirator protection is not normally required. TLV: 5 mg/m3 Protective garments not normally required. Handle with gloves. Choose body protection according to the amount and concentration of the dangerous substance at the work place. Mechanical exhaust required. Safety shower and eye bath. Handle in accordance with good industrial hygiene and safety practice. Wash hands before breaks and at the end of workday. Wash thoroughly after handling. Discard contaminated clothing and shoes. 9. Physical and Chemical Properties Physical States: [ ] Gas [ X ] Liquid [ ] Solid Appearance and Odor: ph: 9.5 Melting Point: Boiling Point: > 212. F (1. C) Flash Pt: Evaporation Rate: Flammability (solid, gas): Clear, Amber. Mild. Explosive Limits: LEL: UEL: Vapor Pressure (vs. Air or mm Hg): Vapor Density (vs. Air = 1): Specific Gravity (Water = 1): 1.1 at 77. F (25. C) Solubility in Water: Complete Percent Volatile: Autoignition Pt: Stability: Conditions To Avoid - Instability: 1. Stability and Reactivity Unstable [ ] Stable [ X ] Incompatibility - Materials To Lead. Tin/tin oxides, Zinc, Strong oxidizing agents. Avoid: Hazardous Decomposition or formed under fire conditions. Sodium oxides, silicon oxides, Carbon monoxide, Carbon Byproducts: dioxide, Nitrogen oxides. Possibility of Hazardous Reactions: Will occur [ ] Will not occur [ X ]
Page: 4 Conditions To Avoid - Hazardous Reactions: Product will not undergo polymerization. 11. Toxicological Information Toxicological Information: Irritation or Corrosion: Carcinogenicity/Other Information: Carcinogenicity: Skin - rabbit - Severe skin irritation - -24 h. Carcinogenicity. IARC: No component of this product present at levels greater than or equal to.1% is identified as probable, possible or confirmed human carcinogen by IARC. ACGIH: No component of this product present at levels greater than or equal to.1% is identified as a carcinogen or potential carcinogen by ACGIH. NTP: No component of this product present at levels greater than or equal to.1% is identified as a known or anticipated carcinogen by NTP. OSHA: No component of this product present at levels greater than or equal to.1% is identified as a carcinogen or potential carcinogen by OSHA. NTP? No IARC Monographs? No OSHA Regulated? No CAS # Hazardous Components (Chemical Name) NTP IARC ACGIH OSHA 131-73-2 Sodium hydroxide n.a. n.a. n.a. n.a. 27177-77-1 Benzenesulfonic acid, dodecyl-, potassium salt n.a. n.a. n.a. n.a. 67-63- Isopropyl alcohol n.a. 3 A4 n.a. 6863-42-9 Cocamide DEA n.a. 2B n.a. n.a. 12-71-6 Triethanolamine n.a. 3 n.a. n.a. 12. Ecological Information Persistence and Degradability: Bioaccumulative Potential: Mobility in Soil: Waste Disposal Method: 13. Disposal Considerations Product: Observe all federal, state, and local environmental regulations. Contaminated packaging: Dispose of as unused product. APPROPRIATE METHOD OF DISPOSAL OF SUBSTANCE OR PREPARATION. 14. Transport Information LAND TRANSPORT (US DOT): DOT Proper Shipping Name: DOT Hazard Class: UN/NA Number: AIR TRANSPORT (ICAO/IATA): ICAO/IATA Shipping Name: Non-Hazardous for Air Transport: Non-hazardous for air transport.
Page: 5 CAS # Hazardous Components (Chemical Name) 15. Regulatory Information EPA SARA (Superfund Amendments and Reauthorization Act of 1986) Lists S. 32 (EHS) S. 34 RQ S. 313 (TRI) 131-73-2 Sodium hydroxide No Yes 1 LB No 27177-77-1 Benzenesulfonic acid, dodecyl-, potassium salt No No No 67-63- Isopropyl alcohol No No Yes 6863-42-9 Cocamide DEA No No No 12-71-6 Triethanolamine No No No This material meets the EPA 'Hazard Categories' defined for SARA Title III Sections 311/312 as indicated: [X] Yes [ ] No Acute (immediate) Health Hazard [ ] Yes [X] No Chronic (delayed) Health Hazard [ ] Yes [X] No Fire Hazard [X] Yes [ ] No Sudden Release of Pressure Hazard [ ] Yes [X] No Reactive Hazard CAS # Hazardous Components (Chemical Name) Other US EPA or State Lists 131-73-2 Sodium hydroxide TSCA: Inventory 27177-77-1 Benzenesulfonic acid, dodecyl-, potassium salt TSCA: Inventory 67-63- Isopropyl alcohol TSCA: Inventory, 4 Test 6863-42-9 Cocamide DEA TSCA: Inventory 12-71-6 Triethanolamine TSCA: Inventory, 8D TERM 16. Other Information Revision Date: 6/11/215 Hazard Rating System: HMIS: HEALTH FLAMMABILITY REACTIVITY PPE 1 Flammability Health NFPA: 1 Instability Special Hazard Additional Information About This Product: Company Policy or Disclaimer: DISCLAIMER: To the best of our knowledge, the information contained herin is accurate. There is no assumption of liability for accuracy contained within this information. The information given is designed only as a guidance for safe handling, use, processing, storage, transportation, disposal and release and is not to be considered a warranty or quality specification. The information relates only to the specific material designated and may not be valid for such material used in combination with any other materials or in any process, unless specified in the text.