SECTION 1 - IDENTIFICATION Product Identifier Product Name: Surgical Instrument Stain Remover Product Code: 3-740 Recommended Use of the Chemical and Restrictions on Use Recommended Use: Used for removing stains and tarnish from surgical instruments. Restrictions on Use: Please be advised that the Instrument Stain Remover (3-740) is not recommended for use on ophthalmic instrumentation unless a verifiable method is employed by the user to determine, with 100% certainty, that all abrasive pumice is removed from the surface of the instrument. Details of the Supplier Manufactured for: Integra York PA, Inc. 589 Davies Dr. York, PA 17402 USA 1-866-854-8300 Emergency Phone Number 24-Hour Number: 1-800-535-5053 International: 1-352-323-3500 Classification of the substance or mixture: SECTION 2 HAZARDS IDENTIFICATION Hazard Class Category Serious Eye Damage/Eye Irritation 2B Skin Corrosion/Irritation 2 Label Elements GHS label elements, including hazard and precautionary statements: Hazard pictogram(s): Signal word: Warning Page 1 of 6 Surgical Instrument Stain Remover (REF 3-740) SDS
Hazard Statement(s): Causes eye irritation. Causes skin irritation. Precautionary Statements: Prevention: Wash skin thoroughly after handling. Wear appropriate chemical resistant gloves, goggles and chemical protective clothing. Response: IF ON SKIN: Wash with plenty of water. Specific treatment - refer to poison center or doctor for advice. If skin irritation occurs: Get Medical advice/attention. Take off contaminated clothing and wash it before reuse. IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. If eye irritation persists: Get medical attention. Components with Unknown Acute Toxicity Oral = 85% Dermal = 85% SECTION 3 COMPOSITION / INFORMATION ON INGREDIENTS Chemical Name CAS Number Concentration % Citric Acid 77-92-9 <15% EMERGENCY AND FIRST AID PROCEDURES: First Aid Measures SECTION 4 FIRST AID MEASURES Skin: If on skin (on hair): Take off immediately all contaminated clothing. Rinse with water/safety shower. Call doctor if irritation persists. Eye Contact: If in eyes: Rinse cautiously for several minutes. Remove contact lenses if present and easy to do. Continue rinsing. If irritated, call doctor. Ingestion: If swallowed: Rinse mouth. Do NOT induce vomiting. Most Important Symptoms and Effects (Acute and Delayed) Eye Contact: Irritation of eyes and skin. Skin: This product can cause mild, transient skin irritation. The severity of irritation will depend on the amount of material that is applied to the skin and the speed and thoroughness that it is removed. Symptoms include redness, itching, and burning of the skin. Repeated or prolonged skin contact can produce moderate irritation (dermatitis). Page 2 of 6 Surgical Instrument Stain Remover (REF 3-740) SDS
Indication of any Immediate Medical Attention and Special Treatment Needed Provide general supportive measures and treat symptomatically. Symptoms may be delayed. Keep victim under observation. Extinguishing Media SECTION 5 FIRE-FIGHTING MEASURES Suitable/Unsuitable: Will not burn or support combustion. Use extinguishing media appropriate for surrounding fire, such as water spray, dry chemical, foam or carbon dioxide. Specific Hazards Arising from Chemical Carbon oxides may be produced. Protective Equipment and Precautions for Firefighters Wear chemical resistant protective equipment and self-contained breathing apparatus (SCBA). SECTION 6 ACCIDENTAL RELEASE MEASURES Methods and Material for Containment and Cleaning Up Steps to be taken in case material is released or spilled: Stop spill at source. Caution: Spilled material may be slippery. If trained in accordance with 29 CFR 1910.120, leaks should be stopped. Spills should be contained and cleaned immediately. Persons performing clean up work should wear adequate personal protective equipment and clothing. Spills and releases should be reported, if required, to the appropriate local, state and federal regulatory agencies. Sweep up and return to container. Waste Disposal Method: Dispose of in accordance with all applicable federal, state, and local regulations. Precautions for Safe Handling SECTION 7 HANDLING AND STORAGE Handling: Wash hands thoroughly after handling. Wear appropriate chemical resistant gloves, goggles and chemical protective clothing. Eating, drinking and smoking in the work area is prohibited. Conditions for Safe Storage, Including any Incompatibilities Storage Conditions: Keep container tightly closed. Incompatible Materials: None identified. Page 3 of 6 Surgical Instrument Stain Remover (REF 3-740) SDS
Control Parameters Exposure Guidelines: SECTION 8 EXPOSURE CONTROL / PERSONAL PROTECTION Chemical Name ACGIH TLV OSHA PEL NIOSH IDLH Appropriate Engineering Controls None defined. Individual Protection Measures Citric Acid Not established Not established Not established Respiratory Protection: None defined. Skin and Body Protection: Wear appropriate chemical resistant gloves. Eye/Face Protection: Wear chemical safety glasses. General Work/Hygienic Practices: Eating, drinking and smoking in the work area is prohibited. SECTION 9 PHYSICAL AND CHEMICAL PROPERTIES Appearance: White to off-white granular mixture Odor: No odor Odor threshold: Not applicable. ph: 2.5 3.5 (5% solution) Melting point/freezing point: Not applicable. Initial boiling point and boiling range: Not applicable. Flash point: None Evaporation rate: Not applicable. Flammability (solid, gas): Non flammable Upper/lower flammability or explosive limits: Not applicable. Vapor pressure: Not applicable. Vapor density: Not applicable. Relative density: Not applicable. Page 4 of 6 Surgical Instrument Stain Remover (REF 3-740) SDS
Solubility(ies): Partially soluble 15 g powder/100 g water Partition coefficient (n-octanol/water): Not applicable. Auto-ignition temperature: Not applicable. Decomposition temperature: Not applicable. Viscosity: Not applicable. SECTION 10 STABILITY AND REACTIVITY Reactivity: Hazardous polymerization will not occur. Chemical stability: Stable under normal conditions. Possibility of hazardous reactions: Hazardous polymerization does not occur. Conditions to avoid: Not specified. Incompatible materials: Avoid contact with strong oxidizers and strong acids. Hazardous decomposition products: Not specified. SECTION 11 TOXICOLOGICAL INFORMATION Oral Administration: Citric Acid-LD50(rat)-5400 mg/kg Dermal administration: Citric Acid-LD50(Rat)-200 mg/kg Immediate effects: Irritation/ burns of skin and eyes. Cancer Hazard: Not listed by IARC, NTP, OSHA, ACGIH Routes of Exposure Eyes, Skin, Inhalation, Ingestion SECTION 12 ECOLOGICAL INFORMATION Ecotoxicity: Not specified. Persistence and degradability: Will biodegrade readily Bioaccumulative potential: Unlikely Mobility in soil: Not specified. Other adverse effects: Not specified. Page 5 of 6 Surgical Instrument Stain Remover (REF 3-740) SDS
SECTION 13 DISPOSAL CONSIDERATIONS Dispose of the product and container in accordance with all applicable local, state, and federal regulations. Department of Transportation: Not D.O.T regulated No additional information. SECTION 14 TRANSPORT INFORMATION SECTION 15 REGULATORY INFORMATION SECTION 16 OTHER INFORMATION HMIS: Health: 1 Flammability: 0 Reactivity: 0 Issue Date: 11/09/2015 Revision Date: 02/26/2018 Liability Disclaimer: SDS information is provided based on OSHA s Hazardous Communication Regulation and for use of the persons required to receive this information under this regulation. The information is neither designed nor recommended for any other use or for use by any other person, including compliance with other laws. Integra York PA, Inc. (the Company ) does not warrant the suitability for use of this SDS for any other material or product not specifically identified herein. The Company does not warrant the accuracy or authenticity of this SDS unless it has been obtained directly from the Company, or posted or viewed on a Company website. This SDS is based on information that is believed to be reliable, but may be subject to change as new information becomes available. Because it is not possible to anticipate all conditions of use, additional safety precautions may be required. Since the use of this material is not under the Company s control, each user is responsible for making their own determination as to the safe and proper handling of this material in their own particular use of this material. The Company makes no representation or warranty, either expressed or implied, including as to merchantability or fitness for a particular purpose. Page 6 of 6 Surgical Instrument Stain Remover (REF 3-740) SDS