Revision Date 0105201 1 Revision SAFETY DATA SHEET 1. IDENTIFICATION Product Name Identified uses Resin-based Dental Restorative Material. For dental professionals only. Supplier Contact Person Tokuyama Dental America Inc. Tel: (77) 37 354 (Toll-Free) http:www.tokuyama-dental.comtdccontact.html Manufacturer Emergency Telephone Tokuyama Dental Corporation 3-9, Taitou 1-chome, Taitou-ku, Tokyo 110-0016, Japan TEL: +1-3-335-2261 California Poison Control System - San Francisco Division San Francisco General Hospital Bldg 5 Rm 2A21, 1001 Potrero Ave, San Francisco Emergency telephone number: 1 00 222 1222 E-mail address: coadmin@calpoison.org http:www.calpoison.org National Capital Poison Center 3201 New Mexico Ave, Ste 310, Washington DC Emergency telephone number: 1 00 222 1222 Telephone number: +1 202 362 367 Facsimile numer: +1 202 362 377 E-mail address: pc@poison.org http:www.poison.org 2. HAZARD(S) IDENTIFICATION Appearance Color Odor GHS Pictogram Paste Yellow white, translucent yellow No information available. Signal Word Hazard Statements Precautionary Statements Contains Warning H317 May cause an allergic skin reaction. P20 Wear protective glovesprotective clothingeye protectionface protection. P302+352 IF ON SKIN: Wash with plenty of soap and water. P333+313 If skin irritation or rash occurs: Get medical adviceattention. P501 Dispose of contentscontainer in accordance with local regulations. bisphenol A di(2-hydroxy propoxy) dimethacrylate triethylene glycol dimethacrylate
2 Hazard Not Otherwise Classified (HNOC) OSHA Regulatory Status Physical and Chemical Hazards Not classified. Human health Environment This Product is Hazardous under the OSHA Hazard Communication Standard. General Information Skin Sens. 1 - H317 Not classified. IF SWALLOWED: Slightly irritating. ( DIGESTIVE SYSTEM. ) May be slightly irritating to skin and eyes. May cause sensitization by skin contact. 3. COMPOSITIONINFORMATION ON INGREDIENTS bisphenol A di(2-hydroxy propoxy) dimethacrylate 10-30% CAS No.: 1565-94-2 EC No.: 216-367-7 Skin Sens. 1 - H317; Aquatic Chronic 3 - H412 camphorquinone < 1% CAS No.: 10373-7-1 EC No.: 233-14-1 Skin Irrit. 2 - H315 ; Eye Irrit. 2 - H319 ; STOT SE 3 - H335 < 1% CAS No.: 12-37-0 EC No.: 204-1-4 Aquatic Chronic 1 - H410 < 1% CAS No.: 150-76-5 EC No.: 205-769- Acute Tox. 4 - H302; Eye Irrit. 2 - H319; Skin Sens. 1 - H317 triethylene glycol dimethacrylate 5-10% CAS No.: 109-16-0 EC No.: 203-652-6 Skin Irrit. 2 - H315; Eye Irrit. 2 - H319; Skin Sens. 1 - H317 4. FIRST-AID MEASURES
3 Description of first aid measures General Information Move the exposed person to fresh air at once. Get medical attention if any discomfort continues. Inhalation Move the exposed person to fresh air at once. Ingestion Try to induce vomiting. Get medical attention if any discomfort continues. Skin Contact Wash the skin immediately with soap and water. Eye Contact Make sure to remove any contact lenses from the eyes before rinsing. Promptly wash eyes with plenty of water while lifting the eye lids. Continue to rinse for at least 15 minutes. Contact physician if irritation persists. Most important symptoms and effects, both acute and delayed Ingestion Slightly irritating. ( DIGESTIVE SYSTEM. ) Skin Contact Slightly irritating. May cause sensitization by skin contact. Eye Contact Slightly Irritating. Indication of any immediate medical attention and special treatment needed Notes To The Physician CAUTION! First aid personnel must be aware of own risk during rescue! Wear suitable protective clothing. 5. FIRE-FIGHTING MEASURES Auto Ignition Temperature ( C) Flammability Limit - Lower(%) Flammability Limit - Upper(%) Flash point ( C) Extinguishing Media Fire can be extinguished using: Foam. Carbon dioxide or dry powder. Specific Hazards When heated and in case of fire, irritating vaporsgases may be formed. Special Fire Fighting Procedures Avoid breathing fire vapors. Protective Equipment For Fire-Fighters Wear full protective clothing. 6. ACCIDENTAL RELEASE MEASURES Personal Precautions Wear protective clothing as described in Section of this material safety data sheet. Environmental Precautions Do not allow to enter drains, sewers or watercourses. Spill Clean Up Methods Extinguish all ignition sources. Avoid sparks, flames, heat and smoking. Ventilate. Absorb in vermiculite, dry sand or earth and place into containers. Reference to other sections For personal protection, see section. 7. HANDLING AND STORAGE Handling All handling to take place in well-ventilated area.
4 Storage Store in a cool, dark place (0-25, 32-77 F). Keep away from heat, direct sunlight, sparks and open flames. Storage Class Chemical storage. Specific end use(s) The identified uses for this product are detailed in Section 1.2.. EXPOSURE CONTROLSPERSONAL PROTECTION COMPONENT STD TWA (-hrs) STEL (15 min) Notes ACGIH 2 mgm3 A4 ACGIH=American Conference of Governmental Industrial Hygienists. A4: Not Classifiable as a Human Carcinogen. Protective Equipment Engineering Measures Provide adequate general and local exhaust ventilation. Respiratory Equipment In case of inadequate ventilation use suitable respirator. Hand Protection Wear protective gloves. Eye Protection Wear approved safety goggles. Other Protection Wear appropriate clothing to prevent any possibility of skin contact. Hygiene Measures DO NOT SMOKE IN WORK AREA! Wash hands at the end of each work shift and before eating, smoking and using the toilet. Wash promptly with soap & water if skin becomes contaminated. Promptly remove any clothing that becomes contaminated. Use appropriate skin cream to prevent drying of skin. When using do not eat, drink or smoke. 9. PHYSICAL AND CHEMICAL PROPERTIES Appearance Paste Color Yellow white, translucent yellow Odor No information available. Solubility No information available. Initial boiling point and boiling range Melting point ( C) Relative density 1.9 Vapor density (air=1) Vapor pressure Evaporation rate ph-value, Conc. Solution 7 ph-value, Diluted Solution Viscosity
5 Decomposition temperature ( C) Odour Threshold, Lower Odour Threshold, Upper Flash point Auto Ignition Temperature ( C) Flammability Limit - Lower(%) Flammability Limit - Upper(%) Partition Coefficient (N-OctanolWater) Explosive properties Other Flammability Oxidising properties 10. STABILITY AND REACTIVITY Reactivity May polymerise. Stability Stable under normal temperature conditions and recommended use. Hazardous reactions: Conditions To Avoid Keep away from heat, sparks and open flame. Protect against direct sunlight. Materials To Avoid Strong oxidizing agents. Hazardous Decomposition Products Toxic gases are generated when heated. 11. TOXICOLOGICAL INFORMATION Acute toxicity: Skin CorrosionIrritation: Slightly irritating. Serious eye damageirritation: Slightly Irritating. Respiratory or skin sensitisation: Respiratory sensitisation Skin sensitisation : May cause sensitization by skin contact. Germ cell mutagenicity:
6 Carcinogenicity: IARC Carcinogenicity Butylated hydroxytoluene (BHT) : IARC Group 3 Not classifiable as to its carcinogenicity to humans. NTP - Carcinogenicity Not listed. OSHA - Carcinogenicity Not listed. Reproductive Toxicity: Specific target organ toxicity - single exposure: STOT - Single exposure Specific target organ toxicity - repeated exposure: STOT - Repeated exposure Aspiration hazard: Viscosity 12. ECOLOGICAL INFORMATION Toxicity No data available. Degradability No data available. Bioaccumulative potential No data available on bioaccumulation. Partition coefficient Mobility: No information available. Results of PBT and vpvb assessment This product does not contain any PBT or vpvb Substances. Other adverse effects Not known. 13. DISPOSAL CONSIDERATIONS Disposal Methods Dispose of waste and residues in accordance with local authority requirements. 14. TRANSPORT INFORMATION General UN No. (DOTTDG) UN No. (IMDG) UN No. (ICAO) DOT Proper Shipping Name Not regulated. NA NA NA DOT Hazard Class No classification noted. DOT Hazard Label No DOT label requirement noted IMDG Class
7 ICAO Class Transport Labels No transport warning sign required. DOT Pack Group IMDG Pack Group Air Pack Group Environmentally Hazardous SubstanceMarine Pollutant No. Special precautions for user Transport in Bulk according to Annex II of MARPOL 737 and the IBC Code Notes 15. REGULATORY INFORMATION Regulatory Status (US) This Product is Hazardous under the OSHA Hazard Communication Standard. Regulatory References 29 CFR 1910. 1200(g) Federal Regulations (OSHA Standard). US Federal Regulations SARA Section 302 Extremely Hazardous Substances Tier II Threshold Planning Quantities CERCLASuperfund, Hazardous SubstancesReportable Quantities (EPA) SARA Extremely Hazardous Substances EPCRA Reportable Quantities SARA 313 Emission Reporting CAA Accidental Release Prevention SARA (311312) Hazard Categories Acute OSHA Highly Hazardous Chemicals US State Regulations California Proposition 65 Carcinogens and Reproductive Toxins California Air Toxics Hot Spots (A-I) California Air Toxics Hot Spots (A-II) Massachusetts "Right To Know" List Rhode Island "Right To Know" List Minnesota "Right To Know" List New Jersey "Right To Know" List
Pennsylvania "Right To Know" List International Inventories EU - EINECSELINCS All ingredients are listed or exempt. Canada DSLNDSL All ingredients are listed or exempt. US - TSCA All ingredients are listed or exempt. US TSCA 12(b) Export Notification 16. OTHER INFORMATION Revision Comments Revision Date 0105201 Revision 3 Disclaimer The information which is contained in this document is based on available data. However, as such has been obtained from various sources, including independent laboratories, it is given without warranty or representation that is complete, accurate and can be relied upon. Tokuyama Dental Corp. has not attempted to conceal in any way the deleterious aspects of the product listed herein, but makes no warranty as to such information.