SECTION I - IDENTIFICATION JEM MFG LLC 1901 Parrish Drive SE Rome, GA 30161 (706) 232-1709 CHEMTREC :... (800) 424-9300 Product Number Product Name Chemical Family CAS Number Date Prepared Revision Number F-588M Multiple 6/1/2015 SECTION II - HAZARDOUS IDENTIFICATION GHS CLASSIFICATION: Classification Skin Corrosion/Irritation Category 2 WARNING! GHS LABEL: Hazard Statements H315 Causes skin irritation Page 1 of 7
Precautionary Statements P264 Wash hands thoroughly after handling. P280 P302+352 P332+313 P362 Wear protective gloves/protective clothing/eye protection/face protection. IF ON SKIN: Wash with soap and water. If skin irritation occurs: get medical advice/attention. Take off contaminated clothing and wash before reuse. SECTION III - COMPOSITION/INFORMATION ON INGREDIENTS The precise composition of this product is proprietary information. In the event of a medical emergency, a complete disclosure will be provided to medical personnel. Component Name CAS # Component% OSHA PEL ACGIH TLV Sodium Hydroxide 1310-73-2 6 2 mg/m³, Ceiling 2 mg/m³, Ceiling Ethylene Glycol Monobutyl Ether Aectate 112-07-2 4 Not Established 20 ppm SECTION IV - FIRST AID MEASURES Contact with eyes: Flush with water for 15 minutes. Seek immediate medical attention. Skin contact: Inhalation: Wash exposed areas with water and mild soap. Remove contaminated clothing immediately and launder before reuse. If irritations persist, seek immediate medical attention. Remove victim to fresh air. Administer oxygen or artificial respiration if breathing is affected or stopped. Seek immediate medical attention. Ingestion: If swallowed. Do not induce vomiting. Seek immediate medical attetntion. Give large quantities of water. Never give anything by mouth to an unconsciuous person. SECTION V - FIREFIGHTING MEASURES Suitable Extinguishing Media: Water fog, foam, CO2, dry chemical. Special Fire Fighting Procedures Gear designed to protect firefighters from wet environment is suitable for fighting fires near this product. Unusual Fire Fighting Hazards: None. Page 2 of 7
SECTION VI - ACCIDENTAL RELEASE MEASURES Personal Precautions: Use appropriate personal protective equipment (i.e. -gloves, goggles, apron, etc.) to minimize risk of exposure to skin and eyes. Environmental Precautions: Contain spill if it can be done with minimal risk. Prevent liquid from entering drains, sewers or waterways. Notify proper authorities. Methods for Cleaning Up: Small Spill: Wipe up or wet vac small spills using proper personal protective equipment. Large Spill: Absorb with water soluble media pads and/or booms. Mop, squeegee, or wet vacuum and containerize for proper disposal. SECTION VII - HANDLING AND STORAGE Handling and Storage: Store out of direct sunlight and in a cool, well-ventilated area. Avoid contact with eyes. Keep from freezing. EXPOSURE LIMITS: SECTION VIII - PRECAUTIONS TO CONTROL EXPOSURE / PERSONAL PROTECTION Component Name CAS # OSHA PEL ACGIH TLV Sodium Hydroxide 1310-73-2 2 mg/m³, Ceiling 2 mg/m³, Ceiling Ethylene Glycol Monobutyl Ether Aectate 112-07-2 Not Established 20 ppm Engineering Controls: Monitoring: Adequate local or mechanical to reduce vapor or mist to below the PEL or TLV. Any clothing or shoes which became contaminated with the product should be removed immediately and thoroughly laundered before wearing again. Personal Protective Equipment (PPE) Eye Protection: Goggles or approved OSHA device with side shields; do not wear contact lenses when handling this product. Skin Protection: Impervious apron and work boots recommend where splashing may occur. Respiratory Protection: Use the proper respirator in areas where the chemical exposure is unknown or above the OSHA PEL or ACGIH TLV. SECTION IX - PHYSICAL AND CHEMICAL PROPERTIES Page 3 of 7
Appearance Odor Safety Data Sheet Clear ph@25 C 12.80 Melting/Freezing Point Flashpoint Specific Gravity Soluability Auto-Ignition Temperature Decomposition Temperature VOC Content Odor Threshold Boiling Range Evaporation Point Flammable Limits - Upper Flammable Limits - Lower Vapor Pressure Vapor Density (Air=1) Viscosity No fragrance N/A None Complete 212 F Slow n/a n/a 350 cps SECTION X - STABILITY AND REACTIVITY Stability: Stable, under normal conditions of storage and handling. Conditions to Avoid: Acids. Hazardous Decomposition/Byproducts: None known Hazardous Polymerization: Will not occur. Polymerization Conditions to Avoid: None Incompatibilities: Strong acids and bases, strong oxidizers Page 4 of 7
SECTION XI - TOXICOLOGICAL INFORMATION Likely Route of Exposure: Contact and inhalation; ingestion possible. Inhalation: May cause irritation to the upper respiratory tract and CNS depression. Eye Contact: Very irritating. Skin Contact: Very irritating. Ingestion: Irritation, possible nausea. Toxicity: Component Name LD50 LC50 Sodium Hydroxide Not Established Not Established Ethylene Glycol Monobutyl Ether Aectate Oral - Rat - 2,400 mg/kg - Dermal - Rabbit - 1,500 mg/kg Not Established Reproductive Effects Teratogenicity Mutagenicity Embryotoxicity Sensitization to Product Synergistic Products SECTION XII - ECOLOGICAL INFORMATION Ecotoxicity: Mobility: Degradability: BioAccumulation: SECTION XIII - WASTE DISPOSAL CONSIDERATIONS Page 5 of 7
DOT SHIPPING INFORMATION Proper Shipping Name: Contains: Hazard Class and Label: 8, UN3266 Identification Number: Packaging Group: Safety Data Sheet SECTION XIV - TRANSPORT INFORMATION Corrosive liquid, basic, inorganic, n.o.s., (containing sodium hydroxi II SECTION XV - REGULATORY INFORMATION TSCA STATUS:... SARA TITLE III SECTION 302/304 EXTREMELY HAZARDOUS SUBSTANCE: No chemicals in this material are subject to the reporting requirements. SARA TITLE III SECTION 311/312 HAZARD CATEGORIZATION: Acute X Chronic Fire Pressure Reactive SARA TITLE III SECTION 313 SUPPLIER INFORMATION: No chemicals in this material are subject to the reporting requirements. CERCLA SECTION 102(a) HAZARDOUS SUBSTANCE: Component Name CAS # % by wt. RQ (lbs.) Sodium Hydroxide 1310-73-2 6 1,000 CALIFORNIA PROPOSITION 65: No chemicals in this material are subject to the reporting requirements. SECTION XVI - OTHER INFORMATION HMIS Health:... 2 HMIS Flammability:... 0 HMIS Reactivity:... 0 Additional: In case of emergency, call CHEMTREC 800-424-9300 Disclaimer -The information in this SDS is given in good faith, but no warranty expressed or implied is made. JEM MFG LLC assumes no responsibility for personal injury or property damage to vendees, users, or third parties caused by the material. As potential misuse of the material cannot be controlled by the manufacturer, vendees or end users assume all risks associated with the use of the material. Page 6 of 7
Page 7 of 7