Material Safety Data Sheet AlkaSolve DL 1. PRODUCT AND COMPANY IDENTIFICATION Product Name Product Identifier MSDS No. Product Family Manufacturer Supplier Emergency Contact Information Use 2. HAZARDS IDENTIFICATION AlkaSolve DL Concentrated Paper Machine Cleaner 0038 Custom Alkaline Cleaners DistriChem-Eco, 20 ave des Terrasses, laval, que, H7L 2C5, Shawn Lapierre, 514-926-0275, www.districhem-eco.com DistriChem-Eco, 20 ave des Terrasses, laval, que, H7L 2C5, Shawn Lapierre, 514-926-0275, www.districhem-eco.com Lab Services, 855 765 8385, 24 hour operation Canutec, 613 996 6666, 24 hour bilingual contact Alkaline concentrated cleaner Potential Health Effects Route of Exposure ; skin contact; eye contact; ingestion. Can cause severe irritation of the nose and throat. Can cause severe lung injury. Avoid repeated or prolonged inhalation of vapors or spray mist which may cause cumulative effects. CORROSIVE. Skin Contact CORROSIVE. May burn the skin. Permanent scarring may result. Eye Contact CORROSIVE. May cause serious eye damage. May irritate or burn the eyes. Permanent damage including blindness may result. Ingestion Permanent damage can result. CORROSIVE. 3. COMPOSITION/INFORMATION ON INGREDIENTS Chemical Name CAS Registry No. Concentration % Other Identifiers Sodium hydroxide 1310-73-2 D-Glucopyranoside, C10_16-alkyl, oligomeric 110615-47-9 Gluconic acid, monosodium salt, D- 527-07-1 4. FIRST AID MEASURES 30-50% 5-10% 5-10% First Aid Procedures Move victim to fresh air. Get medical attention immediately. Skin Contact Immediately flush with lukewarm, gently flowing water for at least 30 minutes. Get medical attention immediately DO NOT INTERRUPT FLUSHING. If it can be done safely, continue flushing during transport to hospital. Eye Contact Immediately flush the contaminated eye(s) with lukewarm, gently flowing water for at least 60 minutes, while holding the eyelid(s) open. If a contact lens is present, DO NOT delay flushing or attempt to remove the lens. Get medical attention immediately. Ingestion NEVER give anything by mouth if victim is rapidly losing consciousness, or is unconscious or convulsing. DO NOT INDUCE VOMITING. Get medical attention immediately. 0038 Page 01 of 05
First Aid Comments Note to Physicians Some of the first aid procedures recommended here require advanced first aid training. Individuals with chronic respiratory disorders such as asthma, chronic brochitis, emphysema, etc. may be more susceptible to irritating effects. 5. FIRE FIGHTING MEASURES Flammable Properties Does not burn. Suitable Extinguishing Not combustible. Use extinguishing agent suitable for surrounding fire. Media Unsuitable Extinguishing Media Specific Hazards Arising from the Chemical No specific methods required. 6. ACCIDENTAL RELEASE MEASURES Personal Precautions Environmental Precautions Methods for Containment and Clean-up 7. HANDLING AND STORAGE Handling Storage Contaminated surfaces will be extremely slippery. Do not allow into any sewer, on the ground or into any waterway. Contain and soak up spill with absorbent that does not react with spilled product. Avoid contact with skin, eyes and clothing. Wash thoroughly after handling. FOR INDUSTRIAL USE ONLY FOR INDUSTRIAL USE ONLY. Store in an area that is: well-ventilated. Store in the original, labelled, shipping container. KEEP OUT OF THE REACH OF CHILDREN PROTECT PRODUCT FROM FREEZING. 8. EXPOSURE CONTROLS/PERSONAL PROTECTION Exposure Guidelines ACGIH TLV OSHA PEL AIHA WEEL Chemical Name TWA STEL TWA Ceiling Sodium hydroxide 2 mg/m3 2 mg/m3 2 mg/m3 Engineering Controls Provide eyewash and safety shower if contact or splash hazard exists. Personal Protective Equipment (PPE) Eye/Face Protection Wear chemical safety goggles and face shield when contact is possible. Skin Protection Respiratory Protection General Hygiene Considerations 8-hr TWA TWA Wear chemical protective clothing e.g. gloves, aprons, boots. In case of insufficient ventilation wear suitable respiratory equipment. A respiratory protection program that meets OSHA's 29 CFR 1910.134 and ANSI Z88.2 requirements must be followed wheneverworkplace conditions warrant a respirators use. Properly dispose of any contaminated items, including shoes, that cannot be decontaminated. DO NOT re-use. 9. PHYSICAL AND CHEMICAL PROPERTIES Physical State Appearance Liquid Clear amber - brown shiny liquid. 0038 Page 02 of 05
Odour Musty (Sodium hydroxide) Odour Threshold Boiling Point Decomposition Temperature Freezing Point ~ 8 ºC Relative Density (water = 1) ~ 1.22 Solubility in Water Soluble. ph ~ 14.0 Partition Coefficient, n-octanol/water Vapour Pressure Saturated Vapour Concentration Vapour Density (air = 1) Evaporation Rate Flash Point > 100 ºC Lower Flammable/Explosive Limit Upper Flammable/Explosive Limit Auto-ignition Temperature Other Physical Property 1 ph (1%) 13.0 10. STABILITY AND REACTIVITY Chemical Stability Conditions to Avoid Incompatible Materials Hazardous Decomposition Products Possibility of Hazardous Reactions Normally stable. Avoid aluminum and halogenated materials Acidic conditions (low ph). Releases excessive heat on contact with: strong acids (e.g. hydrochloric acid). 11. TOXICOLOGICAL INFORMATION LC50: LD50 (oral): LD50 (dermal): Skin Irritation / Corrosion Human experience shows skin corrosion. Eye Irritation / Corrosion Human experience shows corrosive eye damage. Effects of Short-Term (Acute) Exposure Skin Absorption 0038 Page 03 of 05
Ingestion Effects of Long-Term (Chronic) Exposure Respiratory and/or Skin Sensitization Carcinogenicity Not specifically evaluated. Teratogenicity / Embryotoxicity Reproductive Toxicity Mutagenicity Toxicologically Synergistic Materials 12. ECOLOGICAL INFORMATION General Comments Environmental information was not located. 13. DISPOSAL CONSIDERATIONS Undiluted product is regulated under environmental and transportation laws as a corrosive waste. Dispose of according to all federal, state and local applicable regulations. RCRA Hazard class D002 RCRA Hazard class D001. 14. TRANSPORT INFORMATION Shipping Information Regulation UN No. Shipping Name Class Packing Group Canadian TDG 1824 sodium hydroxide solution (Sodium hydroxide) 8 II Other Transport Information Special Shipping Information Please note: DOT/TDG: Please refer to the Bill of lading/receiving documents for up to date shipping information 15. REGULATORY INFORMATION Canada WHMIS Classification Class E E - Corrosive 0038 Page 04 of 05
This product has been classified in accordance with the hazard criteria of the Controlled Products Regulations and the MSDS contains all of the information required by the Controlled Products Regulations. Domestic Substances List (DSL) / Non-Domestic Substances List (NDSL) All ingredients are listed on the DSL or are not required to be listed. USA US OSHA Regulatory Status This material is considered hazardous by the OSHA Hazard Communication Standard (29 CFR 1910.1200). Toxic Substances Control Act (TSCA) Section 8(b) All ingredients are exempt from TSCA Inventory requirements. Additional USA Regulatory Lists This product is not subject to the reporting requirements under California Proposition 65. 16. OTHER INFORMATION NFPA Rating Health - 3 Instability - 1 Based on Sodium hydroxide MSDS Prepared By Lab Services Phone No. 514 926 0275 Date of Preparation Disclaimer This document has been prepared using data from sources considered technically reliable. It does not constitute a warranty, express or implied, as to the accuracy of the information contained within. Actual conditions of use and handling are beyond sellers control. User is responsible to evaluate all available information when using product for any particular use and to comply with State, Federal, Provincial and local laws and regulations. 0038 Page 05 of 05