Safety Data Sheet B&B Identification of the substance/mixture and of the company/undertaking

Transcription

1 1. Identification of the substance/mixture and of the company/undertaking 1.1. Product identifier Product Identity Alternate Names 1.2. Relevant identified uses of the substance or mixture and uses advised against Intended use Application Method See Technical Data Sheet. See Technical Data Sheet Details of the supplier of the safety data sheet Company Name B&B Tritech INC 875 West 20th Street Hialeah, Florida Emergency CHEMTREC (USA) (800) Customer Service: B&B Tritech INC (305) Hazard identification of the product 2.1. Classification of the substance or mixture Combustible Liquid;H227 Acute Tox. 5;H313 Skin Irrit. 2;H315 Eye Irrit. 2;H319 Aquatic Chronic 2;H411 Combustible Liquid. May be harmful in contact with skin. (Not adopted by US OSHA) Causes skin irritation. Causes serious eye irritation. Toxic to aquatic life with long lasting effects Label elements Using the Toxicity Data listed in section 11 and 12 the product is labeled as follows. H227 Combustible liquid. H313 May be harmful in contact with skin. H315 Causes skin irritation. Warning Page 1 of 10

2 H319 Causes serious eye irritation. H411 Toxic to aquatic life with long lasting effects. [Prevention]: P210 Keep away from heat / sparks / open flames / hot surfaces - No smoking. P264 Wash thoroughly after handling. P273 Avoid release to the environment. P280 Wear protective gloves / eye protection / face protection. [Response]: P IF ON SKIN: Wash with plenty of soap and water. P IF IN EYES: Rinse continuously with water for several minutes. Remove contact lenses if present and easy to do - continue rinsing. P312 Call a POISON CENTER or doctor / physician if you feel unwell. P321 Specific treatment (see information on this label). P If eye irritation persists: Get medical advice / attention. P362 Take off contaminated clothing and wash before reuse. P391 Collect spillage. [Storage]: P Store in a well ventilated place. Keep cool. [Disposal]: P501 Dispose of contents / container in accordance with local / national regulations. 3. Composition/information on ingredients This product contains the following substances that present a hazard within the meaning of the relevant State and Federal Hazardous Substances regulations. Ingredient/Chemical Designations Weight % GHS Classification Notes Solvent naphtha (petroleum), heavy aromatic CAS Number: Asp. Tox. 1;H304 [1] Ingredient B CAS Number: Proprietary Eye Irrit. 2;H319 Skin Irrit. 2;H315 [1][2] Ingredient A CAS Number: Proprietary Acute Tox. 4;H332 Acute Tox. 4;H312 Acute Tox. 4;H302 Eye Irrit. 2;H319 Skin Irrit. 2;H315 [1][2] [1] Substance classified with a health or environmental hazard. [2] Substance with a workplace exposure limit. [3] PBT-substance or vpvb-substance. *The full texts of the phrases are shown in Section 16. Page 2 of 10

3 4. First aid measures 4.1. Description of first aid measures General In all cases of doubt, or when symptoms persist, seek medical attention. Never give anything by mouth to an unconscious person. Inhalation Eyes Skin Ingestion Remove to fresh air, keep patient warm and at rest. If breathing is irregular or stopped, give artificial respiration. If unconscious place in the recovery position and obtain immediate medical attention. Give nothing by mouth. Irrigate copiously with clean water for at least 15 minutes, holding the eyelids apart and seek medical attention. Remove contaminated clothing. Wash skin thoroughly with soap and water or use a recognized skin cleanser. If swallowed obtain immediate medical attention. Keep at rest. Do NOT induce vomiting Most important symptoms and effects, both acute and delayed Overview Exposure to solvent vapor concentrations from the component solvents in excess of the stated occupational exposure limits may result in adverse health effects such as mucous membrane and respiratory system irritation and adverse effects on the kidneys, liver and central nervous system. Symptoms include headache, nausea, dizziness, fatigue, muscular weakness, drowsiness and in extreme cases, loss of consciousness. Repeated or prolonged contact with the preparation may cause removal of natural fat from the skin resulting in dryness, irritation and possible non-allergic contact dermatitis. Solvents may also be absorbed through the skin. Splashes of liquid in the eyes may cause irritation and soreness with possible reversible damage. See section 2 for further details. Eyes Skin Causes serious eye irritation. May be harmful in contact with skin. (Not adopted by US OSHA) Causes skin irritation. 5. Fire-fighting measures 5.1. Extinguishing media Recommended extinguishing media; alcohol resistant foam, CO2, powder 5.2. Special hazards arising from the substance or mixture Hazardous decomposition: Oxides of Carbon Keep away from heat / sparks / open flames / hot surfaces - No smoking Advice for fire-fighters In the event of fire, wear full protective clothing and NIOSH Approved Self-contained breathing apparatus with full face piece operated in the pressure demand or other positive pressure mode. Move container from fire area if it can be done without risk. Use water to keep fire exposed containers cool and disperse vapors. ERG Guide No Page 3 of 10

4 6. Accidental release measures 6.1. Personal precautions, protective equipment and emergency procedures Put on appropriate personal protective equipment (see section 8) Environmental precautions Do not allow spills to enter drains or waterways. Use good personal hygiene practices. Wash hands before eating, drinking, smoking or using toilet. Promptly remove soiled clothing and wash thoroughly before reuse Methods and material for containment and cleaning up Absorb with sand or inert material. May use mop, squeegee or industrial vacuum. Avoid contact with skin and eyes. 7. Handling and storage 7.1. Precautions for safe handling Store in accordance with the National Fire Protection Association's publication NFPA 30, Flammable and Combustible Liquids Code. 29 CFR applies to the handling, storage, and use of flammable and combustible liquids. See section 2 for further details. - [Prevention]: 7.2. Conditions for safe storage, including any incompatibilities Handle containers carefully to prevent damage and spillage. Store in a cool dry area, away from heat, sparks and open flame. Keep containers sealed when not in use. Store out of direct sunlight. Incompatible materials: Avoid contact with strong acids, bases, oxidizers, and reducing agents. See section 2 for further details. - [Storage]: 7.3. Specific end use(s). 8. Exposure controls and personal protection 8.1. Control parameters Exposure CAS No. Ingredient Source Value Solvent naphtha (petroleum), heavy aromatic OSHA ACGIH NIOSH Supplier No Established Limit No Established Limit No Established Limit No Established Limit Page 4 of 10

5 Proprietary Ingredient A OSHA TWA 50 ppm (240 mg/m3) [skin] ACGIH TWA: 20 ppm Revised 2003, NIOSH TWA 5 ppm (24 mg/m3) [skin] Supplier No Established Limit Proprietary Ingredient B OSHA No Established Limit ACGIH Ceiling: 25 ppm NIOSH C 25 ppm (125 mg/m3) Supplier No Established Limit Carcinogen Data CAS No. Ingredient Source Value Solvent naphtha (petroleum), heavy aromatic OSHA NTP IARC Select Carcinogen: No Known: No; Suspected: No Proprietary Ingredient A OSHA Select Carcinogen: No NTP IARC Group 1: No; Group 2a: No; Group 2b: No; Group 3: No; Group 4: No; Known: No; Suspected: No Proprietary Ingredient B OSHA Select Carcinogen: No NTP IARC Group 1: No; Group 2a: No; Group 2b: No; Group 3: Yes; Group 4: No; Known: No; Suspected: No Group 1: No; Group 2a: No; Group 2b: No; Group 3: No; Group 4: No; 8.2. Exposure controls Respiratory Eyes Skin Engineering Controls If workers are exposed to concentrations above the exposure limit they must use the appropriate, certified respirators. Protective safety glasses recommended. Wear chemically resistant boots and apron. Avoid skin contact. Use chemically resistant gloves. Provide adequate ventilation. Where reasonably practicable this should be achieved by the use of local exhaust ventilation and good general extraction. If these are not sufficient to maintain concentrations of particulates and any vapor below occupational exposure limits suitable respiratory protection must be worn. Other Work Practices See section 2 for further details. - [Prevention]: Do not over atomize spray. Use good personal hygiene practices. Wash hands before eating, drinking, smoking or using toilet. Promptly remove soiled clothing and wash thoroughly before reuse. 9. Physical and chemical properties Appearance Odor Odor threshold Brownish Color Liquid Solvent Odor Page 5 of 10

6 ph Melting point / freezing point Initial boiling point and boiling range Flash Point Evaporation rate (Ether = 1) Flammability (solid, gas) Upper/lower flammability or explosive limits Vapor pressure (Pa) Vapor Density Specific Gravity Solubility in Water Partition coefficient n-octanol/water (Log Kow) Auto-ignition temperature Decomposition temperature Viscosity (cst) About 170F 151F Pensky-Martens Closed Cup Slower than ether Not Applicable Lower Explosive Limit: Upper Explosive Limit: 0.95 (H2O=1) Complete Percent Volatile by Volume about Other information No other relevant information. 10. Stability and reactivity Reactivity Hazardous Polymerization will not occur Chemical stability Stable under normal circumstances Possibility of hazardous reactions Conditions to avoid Avoid extreme temperatures, flames, and sparks Incompatible materials Avoid contact with strong acids, bases, oxidizers, and reducing agents Hazardous decomposition products Oxides of Carbon Page 6 of 10

7 11. Toxicological information Acute toxicity Exposure to solvent vapor concentrations from the component solvents in excess of the stated occupational exposure limits may result in adverse health effects such as mucous membrane and respiratory system irritation and adverse effects on the kidneys, liver and central nervous system. Symptoms include headache, nausea, dizziness, fatigue, muscular weakness, drowsiness and in extreme cases, loss of consciousness. Repeated or prolonged contact with the preparation may cause removal of natural fat from the skin resulting in dryness, irritation and possible non-allergic contact dermatitis. Solvents may also be absorbed through the skin. Splashes of liquid in the eyes may cause irritation and soreness with possible reversible damage. Ingredient Oral LD50, mg/kg Skin LD50, mg/kg Inhalation Vapor LD50, mg/l/4hr Inhalation Dust/Mist LD50, mg/l/4hr Inhalation Gas LD50, ppm Solvent naphtha (petroleum), heavy aromatic - ( ) 5,000.00, Rat - Category: 5 2,000.00, Rabbit - Category: 4 Ingredient B - (Proprietary) 3,700.00, Rat - Category: 5 7,892.00, Rabbit - Category: NA Ingredient A - (Proprietary) 1,414.00, Guinea Pig - Category: 4 1,200.00, Guinea Pig - Category: , Guinea Pig - Category: NA Note: When no route specific LD50 data is for an acute toxin, the converted acute toxicity point estimate was used in the calculation of the product's ATE (Acute Toxicity Estimate). Classification Category Hazard Description Acute toxicity (oral) --- Not Applicable Acute toxicity (dermal) 5 May be harmful in contact with skin. (Not adopted by US OSHA) Acute toxicity (inhalation) --- Not Applicable Skin corrosion/irritation 2 Causes skin irritation. Serious eye damage/irritation 2 Causes serious eye irritation. Respiratory sensitization --- Not Applicable Skin sensitization --- Not Applicable Germ cell mutagenicity --- Not Applicable Carcinogenicity --- Not Applicable Reproductive toxicity --- Not Applicable STOT-single exposure --- Not Applicable STOT-repeated exposure --- Not Applicable Aspiration hazard --- Not Applicable Page 7 of 10

8 12. Ecological information Toxicity No additional information provided for this product. See Section 3 for chemical specific data. Toxic to aquatic life with long lasting effects. Aquatic Ecotoxicity Ingredient Solvent naphtha (petroleum), heavy aromatic - ( ) Ingredient B - (Proprietary) 96 hr LC50 fish, mg/l 45.00, Pimephales promelas 10,000.00, Lepomis macrochirus 48 hr EC50 crustacea, mg/l ErC50 algae, mg/l 12.00, Daphnia magna 2.50 (72 hr), Skeletonema costatum 2,800.00, Cerodaphnia reticulata Not Available Ingredient A - (Proprietary) , Fish (Piscis) 1,000.00, Daphnia magna Not Available Persistence and degradability There is no data on the preparation itself Bioaccumulative potential Mobility in soil Results of PBT and vpvb assessment This product contains no PBT/vPvB chemicals Other adverse effects. 13. Disposal considerations Waste treatment methods Observe all federal, state and local regulations when disposing of this substance. Page 8 of 10

9 14. Transport information DOT (Domestic Surface Transportation) IMO / IMDG (Ocean Transportation) ICAO/IATA UN number Not Applicable Not Regulated Not Regulated UN proper shipping name Transport hazard class(es) Not Regulated Not Regulated Not Regulated DOT Hazard Class: Not Applicable DOT Label: --- IMDG: Not Applicable Sub Class: Not Applicable Air Class: Not Applicable Packing group Not Applicable Not Applicable Not Applicable Environmental hazards IMDG Marine Pollutant: Yes ( Solvent naphtha (petroleum), heavy aromatic ) Special precautions for user No further information 15. Regulatory information Regulatory Overview Toxic Substance Control Act ( TSCA) WHMIS Classification US EPA Tier II Hazards The regulatory data in Section 15 is not intended to be all-inclusive, only selected regulations are represented. All components of this material are either listed or exempt from listing on the TSCA Inventory. B3 D2B EPCRA 311/312 Chemicals and RQs: EPCRA 302 Extremely Hazardous : EPCRA 313 Toxic Chemicals: Ingredient A Proposition 65 - Carcinogens (>0.0%): Fire: Yes Sudden Release of Pressure: No Reactive: No Immediate (Acute): Yes Proposition 65 - Developmental Toxins (>0.0%): Proposition 65 - Female Repro Toxins (>0.0%): Proposition 65 - Male Repro Toxins (>0.0%): Delayed (Chronic): No Page 9 of 10

10 N.J. RTK Substances (>1%): Ingredient A Ingredient B Penn RTK Substances (>1%): Ingredient A Ingredient B 16. Other information The information and recommendations contained herein are based upon data believed to be correct. However, no guarantee or warranty of any kind, expressed or implied, is made with respect to the information contained herein. We accept no responsibility and disclaim all liability for any harmful effects which may be caused by exposure to our products. Customers/users of this product must comply with all applicable health and safety laws, regulations, and orders. The full text of the phrases appearing in section 3 is: H302 Harmful if swallowed. H304 May be fatal if swallowed and enters airways. H312 Harmful in contact with skin. H315 Causes skin irritation. H319 Causes serious eye irritation. H332 Harmful if inhaled. This is the first version in the GHS SDS format. Listings of changes from previous versions in other formats are not applicable. End of Document Page 10 of 10